Char-Broil LP Gas Grill manual Safety Tips

Do not use a POL transport plug (plastic part with external threads)! It will defeat the safety feature

of the valve.

5.Hold regulator and insert nipple into LP tank valve. Hand-tighten the coupling nut, holding regulator in a straight line with LP tank valve so as to not cross- thread the connection.

Nipple has to be centered into the LP tank valve.

DANGER

• Do not insert any tool or foreign objects into

the valve outlet or safety relief valve. You may

damage the valve and cause a leak. Leaking

propane may result in explosion, fire, severe

personal injury, or death.

• If a leak is detected at any time, STOP and call

the fire department.

• If you cannot stop a gas leak, immediately

close LP tank valve and call LP gas supplier

or your fire department!

WARNING

• Never attempt to attach this grill to the self-

contained LP gas system of a camper trailer

or motor home.

• Do not use grill until leak-tested.

Hold coupling nut and regulator as shown for proper connection to LP tank valve.

6.Turn the coupling nut clockwise and tighten to a full solid stop. The regulator will seal on the back- check feature in the LP tank valve, resulting in some resistance. An additional one-half to three- quarters turn is required to complete the connection. Tighten by hand only – do not use tools.

NOTE:

If you cannot complete the connection, disconnect regulator and repeat steps 5 and 6. If you are still unable to complete the connection, do not use this

regulator!

Safety Tips

￿Before opening LP tank valve, check the coupling nut for tightness.

￿When grill is not in use, turn off all control knobs and LP tank valve.

￿Never move grill while in operation or still hot.

￿Use long-handled barbecue utensils and oven mitts to avoid burns and splatters.

￿Maximum load for sideburner and side shelf is 10 lbs.

￿Do not use a cooking pot larger than 9” on the sideburner.

￿A soup can or grease cup must be attached to grease clip/grease tray and emptied after each use. Do not remove soup can/grease cup until grill has completely cooled.

￿If you notice grease or other hot material dripping from grill onto valve, hose or regulator, turn off gas supply at once. Determine the cause, correct it, then clean and inspect valve, hose and regulator before continuing. Perform a leak test.

￿The regulator may make a humming or whistling noise during operation. This will not affect safety or use of grill.

￿If you have a grill problem see the "Troubleshooting Section".

7