OTHER
°Do not store gasoline from one sea- son to another.
*Replace your gasoline can if it starts to rust.
TROUBLESHOOTING TABLE
_ WARNING: Always stop unit and discennect spark plug before perform- mg all of the recommended remedies below except remedies that require
operation of the unit.
TROUBLE |
| CAUSE |
|
|
|
|
| REMEDY |
|
|
|
|
|
| |||||
Engine | will | not | 1. Engine | flooded. | 1. | See "Starting | a Flooded | Engine" in | |||||||||||
start. |
|
|
|
|
|
|
|
|
|
| Operation | Section. |
|
|
| ||||
|
|
| 2. | Fuel tank | empty. | 2. | Fill tank | with | correct | fuel | mixture. | ||||||||
|
|
| 3. | Spark | plug | not firing. | 3. | install | new | spark | plug. |
|
| ||||||
|
|
| 4. | Fuel not reaching | 4. | Check | for | dirty fuel | filter; | replace. | |||||||||
|
|
|
| carburetor. |
|
|
|
| Check | for | kinked | or split | fuel | line; | |||||
|
|
|
|
|
|
|
|
|
|
| repair | or replace. |
|
|
|
| |||
|
|
| 5. | Carburetor |
| requires | 5. | Contact Sears Service (see back cover). | |||||||||||
|
|
|
| adjustment. |
|
|
|
|
|
|
|
|
|
|
|
| |||
Engine | will |
| 1. | Carburetor | requires | 1. | See "Carburetor | Adjustment" | in | ||||||||||
not idle |
|
|
| adjustment. |
|
|
| Service and | Adjustments | Section. | |||||||||
properly. |
| 2. | Crankshaft |
| seals worn. | 2. | Contact Sears Service (see back cover). | ||||||||||||
|
|
| 3. | Compression | low. | 3. | Contact Sears Service (see back cover). | ||||||||||||
Engine | will | not | 1. | Air | filter | dirty. |
| 1. | Clean | or | replace | air | filter. |
|
| ||||
accelerate, |
| 2. | Spark | plug | fouled. | 2. | Clean | or | replace | plug and regap. | |||||||||
lacks power, |
| 3. | Carburetor |
| requires | 3. | Contact Sears Service (see back cover). | ||||||||||||
or dies | under |
| adjustment. |
|
|
|
|
|
|
|
|
|
|
|
| ||||
a load. |
|
| 4. | Carbon | 4. | Contact Sears Service (see back cover). | |||||||||||||
|
|
|
| muffler | outlet | screen. |
|
|
|
|
|
|
|
|
|
| |||
|
|
| 5. | Compression | low. | 5. | Contact Sears Service (see back cover). | ||||||||||||
Engine |
|
| 1. | Choke | partially | on. | 1. | Adjust | choke. |
|
|
|
| ||||||
smokes |
|
| 2. | Fuel | mixture | incorrect. | 2. | Empty fuel tank and refill with |
| ||||||||||
_=xcessively. |
|
|
|
|
|
|
|
|
| correct | fuel mixture. |
|
|
| |||||
|
|
| 3. | Air | filter dirty. |
| 3. | Clean | or | replace | air | filter. |
|
| |||||
4.Carburetor requires 4. Contact Sears Service (see back cover), adjustment.
Engine runs | 1. | Fuel mixture | incorrect. | 1. | See "Feeling | Engine" | in Operation | |
not. |
|
|
|
|
| section. |
|
|
| 2. | Spark | plug | incorrect. | 2. | Replace with | correct | spark plug. |
| 3. | Carburetor | requires | 3. | Contact Sears Service (see back cover). | |||
|
| adjustment. |
|
|
|
|
| |
| 4. | Carbon | 4. | Contact Sears Service (see back cover). | ||||
|
| muffler | outlet screen. |
|
|
|
| |
YOUR WARRANTY RIGHTS AND OB-
LIGATIONS: The U.S. Environmental
Protection Agency/California Air Re- sources Board and Sears, Roebuck and Co., U.S.A. are pleased to explain the emissions control system warranty on your year
your small
11
