Generac 004451, 004582, 004451 ,004582 owner manual Charging A Battery, Operation

Section 2 — Operation

Commercial-Industrial-Residential Portable Generator System

2.12 CHARGING A BATTERY

DANGER! Storage batteries give off explosive hydrogen gas while recharging. An explosive mixture will remain around the battery for a long time after it has been charged. The slightest spark can ignite the hydrogen and cause an explosion. Such an explosion can shatter the battery and cause blindness or other serious injury.

DANGER! Do not permit smoking, open flame, sparks or any other source of heat around a battery. Wear protective goggles, rubber apron and rubber gloves when working around a battery. Battery electrolyte fluid is an extremely caustic sulfuric acid solution that can cause severe burns. If spill occurs flush area with clear water immediately.

Your generator has the capability of recharging a discharged 12 Volt automotive or utility style storage battery. Do not use the unit to charge any 6 Volt batteries. Do not use the unit to crank an engine having a discharged battery.

To recharge 12 Volt batteries, proceed as follows:

•Check fluid level in all battery cells. If necessary, add ONLY distilled water to cover separators in battery cells. Do not use tap water.

•If the battery is equipped with vent caps, make sure they are installed and are tight.

•If necessary, clean battery terminals.

•Connect battery charge cable connector plug to panel receptacle identified by the words "12-VOLT D.C."

•Connect battery charge cable clamp with red handle to the positive

(+) battery terminal.

•Connect battery charge cable clamp with black handle to the negative (-) battery terminal.

•Start engine. Let the engine run while battery recharges. Engine idle control switch must be in off position for battery charging.

•When battery has charged, shut down engine.

Note: Use an automotive hydrometer to test battery state of charge and condition. Follow the hydrometer manufacturer's instructions carefully. Generally, a battery is considered to be at 100% state of charge when specific gravity of its fluid (as measured by hydrometer) is 1.260 or higher.

13