Section 1 – General Information
Recreational Vehicle Generator
1.5.5 ENGINE
The manufacturer does not recommend using any gasoline containing alcohol (such as “gaso- hol”). If using any gasoline containing alcohol, it must not contain more than 10 percent ethanol, and it must be removed from the generator dur- ing storage. Do NOT use any gasoline contain- ing methanol. If using gasoline with alcohol, inspect more frequently for fuel leaks and other abnormalities.
1.5.2 OPTIONAL PROPANE FUEL SYSTEM
This generator is equipped with a liquid propane (LP) gas fuel sys- tem. LP gas is usually supplied as a liquid in pressure tanks.
The generator requires a vapor withdrawal type fuel system. This type of gaseous fuel system uses the vapors forming above the liquid fuel in the storage tank. Air temperature around the storage tank must be high enough to sustain adequate fuel vaporization. In colder climates, it may be necessary to use an independent heat source to be sure the fuel sufficiently vaporizes in the storage tank.
LP gas may consist of propane, butane or a mixture of the two gases. Propane vaporizes at temperatures as low as
1.5.3 FUEL CONSUMPTION
| Model |
| No Load | 1/2 Load | Full Load |
|
|
|
|
|
| 0.32 | 0.46 | 0.76 | |
| 0.47/17.05 | 0.72/3.06 | 1.25/45.35 | |
Gasoline is in gal/h. |
|
| ||
LP is in gal/h and cf/h. |
|
| ||
|
|
|
|
|
1.5.4 | ENGINE OIL REQUIREMENTS |
| ||
Use only high quality detergent oil rated with American Petroleum Institute (API) Service Classification SF, SG or SH. The recommended oil weights include the following:
•During summer months: SAE 30. An acceptable substitute is SAE
•During winter months: SAE
Crankcase and oil filter capacity is approximately 1,400 mL or
1.5U.S. quarts. Do NOT use special additives. See "Checking the Engine Oil Level" and "Changing the Engine Oil and/or Oil Filter" sections for oil level check and fill procedures.
Type of Engine ............................................................ | |
Cooling Method ................................................................................ | |
Rated Horsepower................................................................ | 15 @ 4,200 rpm |
Displacement......................................................................................... | 407cc |
Cylinder Block.................................................... | Aluminum w/Cast Iron Sleeve |
Type of Governor ...................................................... | Mechanical, Fixed Speed |
Air Cleaner ................................................. | Paper Element w/Foam Precleaner |
Starter................................................................................. | |
Ignition System.............................................. | |
Recommended Spark Plug |
|
Champion......................................................................................... | RC14YC |
AC.......................................................................................................... | R45S |
Fram Autolite.............................................................................................. | 65 |
Spark Plug Gap................................................................ | 0.030 inch (76 mm) |
Recommended Minimum Battery....................................... | 400 |
| Amperes |
ClassII Emission Compliant |
|
1.5.6 GENERATOR
Rated Maximum Continuous |
|
AC Output (Gasoline)................................................... | 4,800 Watts (4.8 kW) |
AC Output (LP Fuel)..................................................... | 4,500 Watts (4.5 kW) |
Rated Voltage............................................................................. | 120 Volts AC* |
Rated Maximum Continuous |
|
AC Current (Gasoline)............................................................. | 40 Amperes** |
AC Current (LP Fuel)............................................................ | 37.5 Amperes** |
Phase...................................................................................................... | Single |
Rotor RPM.............................................................................................. | 3,600 |
Number of Rotor Poles ................................................................................... | 2 |
Engine RPM............................................................................................ | 2,571 |
Rated AC Frequency............................................................................... | 60 Hz |
Battery Charge Voltage .................................................................. | 14 Volts DC |
Battery Charge Current ......................................................... | 2 Amperes (max) |
Weight |
|
Gasoline...................................................................................... | 198 Pounds |
LP Fuel........................................................................................ | 200 Pounds |
Length.......................................................................... | 25.5 inches (648 mm) |
Width ......................................................................... | 18.88 inches (479 mm) |
Height ........................................................................ | 16.75 inches (425 mm) |
*All units are reconnectable to 120- and/or
**If reconnected for dual voltage, the ampere rating for 240 volts is 20 AC amperes for model
***Maximum wattage and current are subject to, and limited by, such factors as fuel Btu content, ambient temperature, altitude, engine condition, etc.. Maximum power decreases about 3.5% for each 1,000 feet above sea level; and will also decrease about 1% for each 6° C (10° F) above 16° C (60° F) ambient temperature.
6