Manuals / Generac Power Systems / Lawn and Garden / Portable Generator

Generac Power Systems 0046264, 0043733, 0046263, 0046262, 0043734, 0043735 owner manual

Models: 0043735 0043734 0046262 0046263 0046264 0043733

1 64

Download 64 pages 62.31 Kb

Page 31

Image 31

Section 6 — Electrical Data

Guardian Liquid-cooled 40 kW Generators Wiring Diagram - Drawing No. 0E2967

* ACT					161		161	1
* ACT					161		161	1
					160		160	2
			0		CC		56	3
							0	4
			85				85	5
			85				85	5
			HCT		85		85	6


0					* MP1	0/BLACK	0	7
0			WLS			0/BARE	0	8
						0/BARE	0	8
					LOS	79/CLEAR	79	9
					FS	79/CLEAR	79	9
			0		FS		14	10
		12V BATTERY				14	14	11
		12V BATTERY			ID		13	12
(-)			(+)			ALT	13	12
(-)			(+)			ALT
	BLACK			RED		IC
					C T	IC
					C T
				SC
			SM			13
			SM			13
			SC		16	13




					CC

EC1

EH	BLACK	120VAC
EH	WHITE	UTILITY
	GREEN	SUPPLY

LEGEND:

*ACT: ACTUATOR ELECTRONIC GOVERNOR

ALT: DC ALTERNATOR

CC:CONTROL CONTACTOR

EC1:	ENGINE CONNECTOR 1(BLACK)
EH:	ENGINE HEATER
FS:	FUEL SOLENOID
HCT	COOLANT HIGH TEMP. SWITCH
IC:	IGNITION COIL
ID:	IGNITION DISTRIBUTOR
LOS:	LOW OIL PRESSURE SWITCH

*MP1: MAGNETIC PICKUP 1

SC	STARTER CONTACTOR
SM:	STARTER MOTOR
WLS:	WATER LEVEL SENSOR

*ONLY USED ON EMISSIONS MODELS

Generac® Power Systems, Inc. 29

Page 31

Image 31

Generac Power Systems 0046264, 0043733, 0046263, 0046262, 0043734, 0043735 owner manual

Contents

40 kW/Single-phasew INSTALLATIONDEADLY EXHAUST FUMES. OUTDOOR INSTALLATION ONLY 40 kW/Single-phasew 200Amp Transfer SwitchINTRODUCTION ‹CONTENTS‹OPERATION AND MAINTENANCE ‹HOW TO OBTAIN SERVICEIntroduction DANGER GENERAL HAZARDSFIRE HAZARDS ELECTRICAL HAZARDSEXPLOSION HAZARDS 1.2THE GENERATOR 1.4PREPACKAGED TRANSFER SWITCHFigure 1.1 – Single-phase 1.1UNPACKING/INSPECTION1.6MAIN CIRCUIT BREAKER 1.8SPECIFICATIONS‹1.7.3 LOW COOLANT LEVEL SWITCH ‹1.7.1 LOW OIL PRESSURE SWITCH‹1.9.1 CONVERSION TO LP GAS VAPOR 1.9FUEL REQUIREMENTS AND RECOMMENDATIONS‹1.8.2 GENERATOR AND LOAD COMPATIBILITY ‹ 1.8.3 ENGINE‹1.12.1 AIR FUEL RATIO CONTROLLER 1.12 EMISSIONS CONTROL SYSTEM1.11 COOLANT 1.10 ENGINE OIL RECOMMENDATIONSOTHER PUBLISHED STANDARDS STANDBY GENERATOR INSTALLATION2.1BASIC STANDBY ELECTRIC SYSTEM NFPA STANDARDSMETHOD 2.6TRANSFER SWITCH START SIGNAL CONNECTIONS‹2.6.1 PRE-PACKAGEDTYPE SWITCH ‹2.6.2 “GTS” Type Engineered SwitchDANGER 2.7BATTERY INSTALLATION2.8PREPARATION BEFORE START-UP ‹2.7.1 VENTED BATTERIES‹2.8.4 GENERATOR SET LUBRICATION ‹2.8.2 TRANSFER SWITCH‹2.8.1 PRIOR TO INITIAL START-UP ‹2.8.3 FUEL SYSTEM3.1 CONTROL CONSOLE COMPONENTS 3.2USING THE AUTO/OFF/MANUAL SWITCH‹3.2.2 “OFF” POSITION 3.4SEQUENCE OF AUTOMATIC OPERATION3.5ENGINE HEATER 3.3AUTOMATIC TRANSFER OPERATIONOUTLET INLET 3.6WEEKLY EXERCISE CYCLE4.1CHECKING THE ENGINE OIL LEVEL Figure 3.2 – Engine Block Heater‹4.2.1 ENGINE OIL RECOMMENDATIONS 4.3CHANGING THE ENGINE AIR CLEANER‹4.2.2 OIL AND FILTER CHANGE PROCEDURE 4.2CHANGING THE ENGINE OIL AND FILTERFigure 4.4 – Setting the Spark Plug Gap 4.5BATTERY MAINTENANCE‹4.5.1 BATTERY REPLACEMENT Figure 4.3 – Engine Air Cleaner4.7OVERLOAD PROTECTION FOR 4.10 MISCELLANEOUS MAINTENANCE‹4.10.1 CLEANING THE GENERATOR 4.6COOLING SYSTEM‹4.11.1 REMOVAL FROM SERVICE 4.11 OUT OF SERVICE PROCEDURE‹4.11.2 RETURN TO SERVICE 4.12 SERVICE SCHEDULE CORRECTION 5.1TROUBLESHOOTING GUIDEPROBLEM CAUSEGuardian Liquid-cooled40 kW Generator Mounting Dimensions - Drawing No. 0D5335Generac Power Systems, Inc. Section 6 — Electrical DataGCB - GOVERNOR CONTROL BOARD HZ - FREQUENCY METER BLACK REDS16 BLUE BLUELiquid-cooled40 Electrical DataModel No 4.3L - DrawingLEGEND 24 Generac Power Systems, IncSection 6 — Electrical Data kW GeneratorSection 6 — Generac Power Systems, IncSCHEMATIC WIRING DIAGRAMModel No. 0046262 Wiring Diagram - Control Panel26 Generac Power Systems, Inc Section 6 — Electrical DataModel No Generac Power Systems, IncSection 6 — Electrical DataFS EH Page Drain DESCRIPTION Section 7 — Exploded Views and Parts ListsITEM PART NOCompartment - Drawing No. 0D8992 Section 7 — Exploded Views and Parts Lists32 Generac Power Systems, Inc Guardian Liquid-cooled40 kW GeneratorsDESCRIPTION Section 7 — Exploded Views and Parts ListsITEM PART NO34 Generac Power Systems, Inc Section 7 - Exploded Views and Parts ListsPANEL FACE DESCRIPTION Section 7 - Exploded Views and Parts ListsITEM PART NO36 Generac Power Systems, Inc Section 7 - Exploded Views and Parts ListsDESCRIPTION Section 7 - Exploded Views and Parts ListsITEM PART NOALT LEADS & SENSING WIRE Guardian Liquid-cooled40 kW Generators Section 7 — Exploded Views and Parts ListsPART NO DESCRIPTIONTO ENGINE FLYWHEEL DESCRIPTION Section 7 — Exploded Views and Parts ListsITEM PART NO42 Generac Power Systems, Inc Section 7 — Exploded Views and Parts ListsDESCRIPTION Section 7 — Exploded Views and Parts ListsITEM PART NOEngine – Drawing No. 0A4304-L 44 Generac Power Systems, Inc6 31 32 Guardian Liquid-cooled40 kW GeneratorsDESCRIPTION Section 7 — Exploded Views and Parts ListsITEM PART NOGuardian Liquid-cooled40 kW Generators Section 7 — Exploded Views and Parts Lists4.3L Radiator – Drawing No. 0D7992-D DESCRIPTION Section 7 — Exploded Views and Parts ListsITEM PART NODESCRIPTION Section 7 — Exploded Views and Parts ListsITEM PART NOPART NO Section 7 — Exploded Views and Parts Lists4.3L Air Cleaner - Drawing No. 0E0712 ITEM12 11 DESCRIPTION Section 7 — Exploded Views and Parts ListsITEM PART NOATTACH TO Section 7 — Exploded Views and Parts ListsDESCRIPTION Section 7 — Exploded Views and Parts ListsITEM PART NO54 Generac Power Systems, Inc Section 7 — Exploded Views and Parts ListsDESCRIPTION Section 7 — Exploded Views and Parts ListsITEM PART NO098290 Section 7 — Exploded Views and Parts ListsPART NO DESCRIPTIONGuardian Liquid-cooled40 kW Generators Section 7 — Exploded Views and Parts ListsITEM DESCRIPTIONSection 8 – Notes 58 Generac Power Systems, IncGuardian Liquid-cooled40 kW Generators Section 8 – Notes Generac Power Systems, Inc.Guardian Liquid-cooled40 kW Generators CALIFORNIA EMISSION CONTROL WARRANTY STATEMENT YOUR WARRANTY RIGHTS AND OBLIGATIONSPURCHASER’S/OWNER’S WARRANTY RESPONSIBILITIES 1-800-333-1322EMISSION RELATED PARTS INCLUDE THE FOLLOWING EMISSION CONTROL SYSTEM WARRANTYSection 9 – Warranty P.O. BOX WHITEWATER, WI WARRANTY SCHEDULESection 9 – Warranty GUARDIAN “EMERGENCY AUTOMATIC STANDBY GENERATORS”