Main
MT VERNON PELLET INSERT ADVANCED ENERGY (AE)
Owners Manual
Installation and Operation
Models:
NOTICE
SAMPLE
H
CAUTION
Masonry orZero Clearance
LABEL LOCATION: On Beaded Chain on e behind Right Side Panel
TABLE OF CONTENTS
Section 1: Listing and Code Approvals
Section 2: Getting Started
Section 3: Dimensions & Clearances
Section 4: Vent Information
A. Appliance Certication
C. Glass Specications
E. BTU & Efciency Specications
B. Mobile Home Approved
D. Electrical Rating
.
A
Design, Installation & Location Considerations
B. Locating Your Appliance & Chimney E. Negative Pressure
C. Wall Control, Thermostat
D. Draft
F. Fire Safety
G. Tools And Supplies Needed
H. Inspect Appliance & Components and Pre-Use Check List
Page 8 7036-135E September 1, 2008
3
A. Appliance Dimensions
29-3/4 in. (756mm) 23-7/8 in. (605mm) 28-1/8 in. (714mm)
33 in. (838mm)
September 1, 2008 7036-135E Page 9
A C
B
Built-in Unit - Rear Vent with Outside Air
Outside Air
E
E. Minimum Opening for Masonry and Zero Clearance Fireplaces
C. Masonry and Zero Clearance Fireplaces
D. Floor Protection
F. Mantel Projections J K
Built-In Vertical
G. Removing Metal Floor of Factory-Built Firebox
4
A. Venting Termination Minimum Requirements
NOTICE: Termination must exhaust above air inlet elevation.
B. Chimney and Exhaust Connection
C. Equivalent Feet of Pipe
Example of 3 Elbow-Rear Vent Termination Calculation
D. Pipe Selection Chart
5
A. Direct Connect Without Outside Air B. Direct Connect With Outside Air
WARNING
C. Full Reline With Outside Air
NOTE: In Canada only a full reline is allowed per ULC S628, ORD ULC C1482-M1990.
6
A. Mobile Home Installation
7
A. Leveling System B. Outside Air Kit Instructions
C. Hearth Support
D. Removal of Cast Sides
E. Panel and Trim Set - Cast
F. Panel & Trim Set, Basic
G. Optional Log Set Placement Instructions
2 PIECE LOG SET INSTALLATION
H. Wall Control Thermostat Installation
September 1, 2008 7036-135E Page 23
8
2. Other Fuels
A. Fuel Size, Material and Storage
1. Wood Pellets
C. Before Your First Fire
D. Starting Your First Fire
FUEL SELECTION
B. General Operating Information
See Wall Control Thermostat Manual for detailed operating instructions.
E. Fire Characteristics and Flame Height Adjustment
F. Battery Back-up System (Optional)
CAUTION
G. Ignition Cycles
- - - - -
September 1, 2008 7036-135E Page 27
H. Quick Start Guide
NOTICE:
CHOOSING FUEL TYPE
TURNING ON APPLIANCE
Wall Control for Reference
CHOOSING TEMP UNIT: F or C
SETTING HEAT OUTPUT
H. Quick Start Guide (Contd)
SETTING COMFORT LEVEL
I. Frequently Asked Questions ISSUES SOLUTIONS
9
Error Message
10
September 1, 2008 7036-135E Page 31
10
A. Proper Shutdown Procedure
Manual Off
Automatic
Figure 31.1
Follow the detailed instructions found in this section for each step listed in the chart below.
C. General Maintenance and Cleaning
Clinker
Page
Page
Page
Ash Build Up in Firebox
Pellets Back Up In Feed Tube
Firepot Overfills
D. High Ash Fuel Content Maintenance
E. Bafe Removal
F. Glass Replacement
11
When describing the location of a component, it is always AS YOU FACE THE FRONT OF THE APPLIANCE.
A. Component Functions
Page
B. Component Locations
C. Exploded Views
Page
D. Service Parts and Accessories
Item No. Accessories Part No.
Page
Page
Item No. Appliance Part No.
Page
Page
Page
G. Warranty Policy
Page
CONTACTINFORMATION:
NOTICE
