Fueling Instructions | Husqvarna HUV 4421-D / DXP, HUV 4421-G / GXP

Fueling Instructions

Air Filter Removal

1.Raise the cargo bed, and locate the air filter canister.

2.Release both canister tab locks (Figure 35).

3.Pull the canister cap away from the canister.

4.Remove the air filter cartridge (1). See following NOTE.

NOTE: The air filter cartridge is specifically designed for this engine. It only fits into the canister one way. Use only the Husqvarna part (P/N 603 00 00-10) designed for this engine.

1

Figure 35 Air Filter Cartridge

Air Filter Installation

1.Push the new air filter cartridge onto the nozzle inside the canister.

2.Place the canister cap, marked TOP, on the top center of the canister.

3.Secure the canister cap with both tab locks.

FUELING INSTRUCTIONS

See General Warnings on page 8.

ýDAN G E R

•Turn key switch to the OFF position before fueling.

•Never pour fuel into the fuel tank when the engine is hot or while it is running.

•To avoid electric arc caused by static electricity, the fuel storage/pumping device must be grounded. If the pump is not grounded, the vehicle must be grounded to the pump before and during the fueling operation.

•To avoid the possibility of fire, clean up any spilled fuel before operating the vehicle.

1.Remove the fuel cap and fill the tank with fuel. Gasoline vehicles have a black fuel cap; diesel vehicles have a green fuel cap. See preceding DANGER and following NOTE.

2007 HUV 4421 Gasoline and Diesel Vehicle Owner’s Manual

Page 43

Image 45

Husqvarna HUV 4421-D / DXP, HUV 4421-G / GXP owner manual Fueling Instructions, Air Filter Removal, Air Filter Installation

Contents

2007 Utility Vehicles Page USA Foreword Table of Contents ALL HUV 4421 Models DRIVER/PASSENGER Warning Decal Rotating Parts Decal Diesel Vehicle Feature Identification Safety Details DAN G E R Caut IONCaut ION DAN G E R General Warnings All-wheel Drive Warning General Information Controls and IndicatorsModel Identification See General Warnings on Controls and Indicators KEY Switch Diesel Vehicles KEY Switch Gasoline VehiclesFORWARD/REVERSE Control Accelerator Pedal Volt Accessory Outlet Steering Adjustment LockBrake Pedal Park Brake LOW OIL Warning Light HIGH-TEMPERATURE Warning Light Diesel Vehicles onlyFuel GAUGE/HOUR Meter Headlight Control Release Safety Belt ROLL-OVER Protective Structure and Safety Belts ING Seat Latch and Adjustment Exhaust system Check for leaks PRE-OPERATION and Daily Safety Checklist Driving Instructions Performance Inspection Starting the Vehicle ALL-WHEEL Drive AWD Operation BED Latch and Prop ROD Stopping the VehicleParking and Leaving the Vehicle Bed Latch Loading and Unloading Cargo Vehicle Load Capacities Transporting on a Trailer Towing with the Vehicle See General Warnings on DAN G E R Storage OFF Preparing the Vehicle for Extended Storage Gasoline vehicles Returning the Stored Vehicle to Service Maintenance Maintenance Periodic Service Schedule Periodic Service Schedule Monthly service by owner Annual service by Periodic Lubrication Schedule Periodic Lubrication Schedule Lubrication Points Gasoline Vehicles Engine OIL Brake Fluid ReservoirBrake Fluid OIL Pressure Gasoline Engine Do not remove dipstick while engine is running Engine OIL Level Check Engine Oil Draining Engine OIL and Filter Change Drain the engine oil. See Engine Oil Draining on Engine Oil Filter Change Remove Engine Oil Filter OIL Viscosity Engine Oil Filling Front differential Gearcase Lubrication Rear differential Transmission Engine Coolant Diesel Vehicles AIR Filter ReplacementAIR Intake System Engine Coolant Level Check Air Filter Installation Fueling InstructionsAir Filter Removal Fuel Tank Gasoline Vehicles Biodiesel Fuel Diesel Vehicles Only Diesel Vehicles Only Draining Water from Fuel Filter Fuel Filter Battery Battery Jump Starting Using a Booster Battery Jump Starting Accessories Cleaning the VehicleElectric Winch Accessory See following Note MUD Tire Option Subsequent Owner Registration Specifications Vehicle Specifications DIMENSIONS/WEIGHT Tire Pressure Warranty Information Technical & Consumer Information Gasoline Engines Carburetor Modification for High Altitude OperationOxygenated Fuels Problems That May Affect Emissions U.S. and California Clean Air ActsReplacement Parts Maintenance Your Warranty Rights and Obligations California Emission Control Warranty StatementPage Page Page Husqvarna Part Number 531 30 Edition Code 0706C0307B