Manuals / Husqvarna / Lawn and Garden / Utility Vehicle

Husqvarna HUV 4421-D / DXP, HUV 4421-G / GXP owner manual ý WARNING, Battery, Page

Models: HUV 4421-D / DXP HUV 4421-G / GXP

1 64

Download 64 pages 60.61 Kb

Page 49

Manual background

Battery

The battery in this vehicle is a 12-volt, low-maintenance battery that requires infrequent checks (Figure 39). Electrolyte level should be checked semiannually.

FRONT

OF VEHICLE

POS

NEG

LEVEL

INDICATOR

BATTERY

CAP

PLATES

ELECTROLYTE LEVEL AT LEAST 1/2-INCH (13 MM)

ABOVE

PLATES OR

TO LEVEL

INDICATOR

Figure 39 Battery

Figure 40 Battery Electrolyte Level

1.Turn the key switch to the OFF position and remove the key. Place the Forward/Reverse handle in the NEUTRAL position. Chock the wheels.

2.Access the engine compartment. See WARNING “For vehicles with cargo beds...” on page 8. 2.1. Remove the driver-side seat.

3.Disconnect the battery cables, negative (–) cable first. See WARNING “To avoid unintentionally start- ing...” on page 9.

4.Use a flat-blade screwdriver, and carefully remove the battery cell caps from the battery. See following

WARNING.

ýWARNING

•Wear safety glasses or approved eye protection when servicing the vehicle. Wear a full face shield and rubber gloves when working on or near batteries.

5.Carefully check the electrolyte level and add distilled water if necessary. Do not fill the battery cells above the designated fill line. Replace battery cell caps.

6.Clean both battery terminals with a solution of baking soda and water (1 cup (237 mL) baking soda per 1 gallon (3.8 L) of water). Rinse thoroughly. Do not allow this solution to enter the battery. Tighten battery terminals to 144 in-lb (16 N·m). Let the terminals dry and then spray them with Battery Terminal Protector Spray (P/N 603 00 00-03). See following CAUTION.

ýWARNING

•If battery wire terminals are damaged or corroded, replace or clean them as necessary. Failure to do so may cause them to overheat during operation and could result in a fire, property damage, or personal injury.

Be sure the battery hold-down clight is properly tightened. Tighten to 9 ft-lb (12.2 N·m). A loose clight may allow the battery to become damaged from vibration or jarring.

If battery appears weak, have it charged by a trained technician. The battery should never be left discharged any longer than absolutely necessary (do not leave discharged overnight).

2007 HUV 4421 Gasoline and Diesel Vehicle Owner’s Manual

Page 47

Image 49

Husqvarna HUV 4421-D / DXP, HUV 4421-G / GXP ý WARNING, Battery, HUV 4421 Gasoline and Diesel Vehicle Owner’s Manual, Page

Contents

Owner’s Manual 2007 Utility VehiclesGasoline and Diesel HUV 4421-G / GXP HUV 4421-D / DXPPage Page 2007 HUV 4421 Gasoline and Diesel Vehicle Owner’s ManualHusqvarna Forest and Garden 7349 Statesville Rd Charlotte, NC USA Page 2 2007 HUV 4421 Gasoline and Diesel Vehicle Owner’s Manual FOREWORD2007 HUV 4421 Gasoline and Diesel Vehicle Owner’s Manual TABLE OF CONTENTSPage ALL HUV 4421 MODELS Vehicle Feature IdentificationPage 4 2007 HUV 4421 Gasoline and Diesel Vehicle Owner’s Manual ON VEHICLE FRAME NEAR BATTERYALL HUV 4421 MODELS Vehicle Feature Identification2007 HUV 4421 Gasoline and Diesel Vehicle Owner’s Manual PageVehicle Feature Identification Page 6 2007 HUV 4421 Gasoline and Diesel Vehicle Owner’s ManualSafety Details SAFETY DETAILSý WARNING ý DAN G E RGeneral Warnings GENERAL WARNINGSPage 8 2007 HUV 4421 Gasoline and Diesel Vehicle Owner’s Manual ý DAN G E RGeneral Warnings ý WARNINGTo avoid unintentionally starting the vehicle 2007 HUV 4421 Gasoline and Diesel Vehicle Owner’s ManualGENERAL INFORMATION CONTROLS AND INDICATORSMODEL IDENTIFICATION See General Warnings on page ý WARNING2007 HUV 4421 Gasoline and Diesel Vehicle Owner’s Manual Controls and IndicatorsPage Figure 4 Instrument Panel - Gasoline VehiclesKEY SWITCH - DIESEL VEHICLES KEY SWITCH - GASOLINE VEHICLESFORWARD/REVERSE CONTROL ACCELERATOR PEDAL12-VOLT ACCESSORY OUTLET STEERING ADJUSTMENT LOCKBRAKE PEDAL PARK BRAKELOW OIL WARNING LIGHT HIGH-TEMPERATURE WARNING LIGHT DIESEL VEHICLES ONLYFUEL GAUGE/HOUR METER HEADLIGHT CONTROLRoll-Over Protective Structure and Safety Belts ROLL-OVER PROTECTIVE STRUCTURE AND SAFETY BELTSý WARNING ý WARNINGSeat Latch and Adjustment SEAT LATCH AND ADJUSTMENTPage 16 2007 HUV 4421 Gasoline and Diesel Vehicle Owner’s Manual ý WARNINGPre-Operation and Daily Safety Checklist PRE-OPERATION AND DAILY SAFETY CHECKLISTExhaust system Check for leaks 2007 HUV 4421 Gasoline and Diesel Vehicle Owner’s ManualDRIVING INSTRUCTIONS PERFORMANCE INSPECTIONPerformance Inspection Page 18 2007 HUV 4421 Gasoline and Diesel Vehicle Owner’s ManualDriving Instructions STARTING THE VEHICLEý WARNING 2007 HUV 4421 Gasoline and Diesel Vehicle Owner’s ManualPage 20 2007 HUV 4421 Gasoline and Diesel Vehicle Owner’s Manual ALL-WHEEL DRIVE AWD OPERATIONý WARNING ý WARNINGSTOPPING THE VEHICLE BED LATCH AND PROP RODPARKING AND LEAVING THE VEHICLE See General Warnings on pageLoading and Unloading Cargo LOADING AND UNLOADING CARGOPage 22 2007 HUV 4421 Gasoline and Diesel Vehicle Owner’s Manual ý WARNINGVehicle Load Capacities VEHICLE LOAD CAPACITIESý WARNING 2007 HUV 4421 Gasoline and Diesel Vehicle Owner’s ManualTRANSPORTING ON A TRAILER TOWING WITH THE VEHICLETowing with the Vehicle Page 24 2007 HUV 4421 Gasoline and Diesel Vehicle Owner’s ManualSee General Warnings on page ý DAN G E R STORAGEStorage ý WARNINGPage 26 2007 HUV 4421 Gasoline and Diesel Vehicle Owner’s Manual PREPARING THE VEHICLE FOR EXTENDED STORAGEBatteries in a low state of charge will freeze at low temperatures ý CAUT IONStorage RETURNING THE STORED VEHICLE TO SERVICEGasoline vehicles All vehiclesMaintenance MAINTENANCEPage 28 2007 HUV 4421 Gasoline and Diesel Vehicle Owner’s Manual See General Warnings on pagePERIODIC SERVICE SCHEDULE PERIODIC SERVICE SCHEDULEPeriodic Service Schedule ý WARNINGPERIODIC SERVICE SCHEDULE Page 30 2007 HUV 4421 Gasoline and Diesel Vehicle Owner’s ManualPeriodic Service Schedule SERVICEPeriodic Service Schedule PERIODIC SERVICE SCHEDULESERVICE ý WARNINGPERIODIC LUBRICATION SCHEDULE PERIODIC LUBRICATION SCHEDULEPeriodic Lubrication Schedule Page 32 2007 HUV 4421 Gasoline and Diesel Vehicle Owner’s Manual2007 HUV 4421 Gasoline and Diesel Vehicle Owner’s Manual Periodic Lubrication SchedulePage Figure 14 Lubrication Points - Gasoline VehiclesENGINE OIL BRAKE FLUID RESERVOIRBRAKE FLUID OIL PRESSURE - GASOLINE ENGINEEngine Oil ENGINE OIL LEVEL CHECKý CAUT ION CAUT IONEngine Oil Draining ENGINE OIL AND FILTER CHANGEPage 36 2007 HUV 4421 Gasoline and Diesel Vehicle Owner’s Manual ý WARNINGEngine Oil Engine Oil Filter Change1. Drain the engine oil. See Engine Oil Draining on page 2007 HUV 4421 Gasoline and Diesel Vehicle Owner’s ManualPage 38 2007 HUV 4421 Gasoline and Diesel Vehicle Owner’s Manual NOTE Use only oil filters designed for your engineEngine Oil Figure 26 Remove Engine Oil FilterOIL VISCOSITY Engine Oil FillingCAUT ION Engine OilFront differential GEARCASE LUBRICATIONTransmission Gearcase LubricationRear differential 2007 HUV 4421 Gasoline and Diesel Vehicle Owner’s ManualENGINE COOLANT - DIESEL VEHICLES AIR FILTER REPLACEMENTAIR INTAKE SYSTEM ENGINE COOLANT LEVEL CHECKFUELING INSTRUCTIONS Air Filter InstallationAir Filter Removal Fueling InstructionsPage 44 2007 HUV 4421 Gasoline and Diesel Vehicle Owner’s Manual Biodiesel Fuel Diesel Vehicles OnlyCAUT ION Fueling Instructionsý WARNING DRAINING WATER FROM FUEL FILTER Diesel Vehicles OnlyFueling Instructions 2007 HUV 4421 Gasoline and Diesel Vehicle Owner’s ManualBattery BATTERYPage 46 2007 HUV 4421 Gasoline and Diesel Vehicle Owner’s Manual See General Warnings on page ý DAN G E Rý WARNING Batteryý WARNING 2007 HUV 4421 Gasoline and Diesel Vehicle Owner’s ManualUsing A Booster Battery Jump Starting USING A BOOSTER BATTERY JUMP STARTINGPage 48 2007 HUV 4421 Gasoline and Diesel Vehicle Owner’s Manual ý WARNINGACCESSORIES CLEANING THE VEHICLEELECTRIC WINCH ACCESSORY Cleaning the VehicleMUD TIRE OPTION SUBSEQUENT OWNER REGISTRATIONSubsequent Owner Registration Page 50 2007 HUV 4421 Gasoline and Diesel Vehicle Owner’s ManualSPECIFICATIONS VEHICLE SPECIFICATIONSVehicle Specifications 2007 HUV 4421 Gasoline and Diesel Vehicle Owner’s ManualSPECIFICATIONS Page 52 2007 HUV 4421 Gasoline and Diesel Vehicle Owner’s ManualVehicle Specifications NOTE Items marked with an asterisk * indicate approximate valuesVehicle Specifications SPECIFICATIONS2007 HUV 4421 Gasoline and Diesel Vehicle Owner’s Manual Page1. WARRANTY Page 54 2007 HUV 4421 Gasoline and Diesel Vehicle Owner’s Manual3. VOIDING OF WARRANTY 5. HOW TO MAKE A WARRANTY CLAIMPage 2007 HUV 4421 Gasoline and Diesel Vehicle Owner’s Manual6. DISCLAIMER 7. NO CONSEQUENTIAL DAMAGESPage 56 2007 HUV 4421 Gasoline and Diesel Vehicle Owner’s Manual TECHNICAL & CONSUMER INFORMATION GASOLINE ENGINESCarburetor Modification for High Altitude Operation Oxygenated FuelsProblems That May Affect Emissions The U.S. and California Clean Air ActsReplacement Parts MaintenancePage 58 2007 HUV 4421 Gasoline and Diesel Vehicle Owner’s Manual CALIFORNIA EMISSION CONTROL WARRANTY STATEMENTPage Page Page Edition Code 0706C0307B Husqvarna Part Number 531 30CCI P/N