TROUBLESHOOTING
See appropriate section in manual unless directed to a service center/department.
PROBLEM | CAUSE | CORRECTION | |||
Does not start | 1. | Fuel | 1. | Turn fuel | |
|
| in OFF position. |
|
| |
| 2. | Safety ignition key is not inserted. | 2. | Insert safety ignition key. | |
| 3. | Out of fuel. | 3. | Fill fuel tank with fresh, clean gasoline. | |
| 4. | Throttle in STOP position (or ON/ | 4. | Move throttle to FAST position (or ON/OFF switch to ON position). | |
|
| OFF switch is OFF). |
|
| |
| 5. | Choke in OFF position. | 5. | Move to FULL position. | |
| 6. | Primer not depressed. | 6. | Prime as instructed in the Operation section of this manual. | |
| 7. | Engine is flooded. | 7. | Wait a few minutes before restarting, DO NOT prime. | |
| 8. | Spark plug wire is disconnected. | 8. | Connect wire to spark plug. | |
| 9. | Bad spark plug. | 9. | Replace spark plug. | |
| 10. | Stale fuel. | 10. | Empty fuel tank & carburetor, refill with fresh, clean gasoline. | |
| 11. | Water in fuel. | 11. | Empty fuel tank & carburetor, refill with fresh, clean gasoline. | |
Loss of power | 1. | Spark plug wire loose. | 1. | Reconnect spark plug wire. | |
| 2. | Throwing too much snow. | 2. | Reduce speed and width of swath. | |
| 3. | Fuel tank cap is covered with ice or | 3. | Remove ice and snow on and around fuel tank cap. | |
|
| snow. |
|
| |
| 4. | Dirty or clogged muffler. | 4. | Clean or replace muffler. | |
|
|
|
|
| |
Engine idles or | 1. | Choke is in FULL position. | 1. | Move choke to OFF position. | |
runs roughly | 2. | Blockage in fuel line. | 2. | Clean fuel line. | |
| |||||
| 3. | Stale fuel. | 3. | Empty fuel tank & carburetor, refill with fresh, clean gasoline. | |
| 4. | Water in fuel. | 4. | Empty fuel tank & carburetor, refill with fresh, clean gasoline. | |
| 5. | Carburetor is in need of adjustment | 5. | Contact an authorized service center/department. | |
|
| or overhaul. |
|
| |
Excessive | 1. | Loose parts or damaged augers or | 1. | Tighten all fasteners. Replace damaged parts. If vibration | |
vibration |
| impeller. |
| remains, contact an authorized service center/department. | |
Recoil starter is | 1. | Frozen recoil starter. | 1. | See “IF RECOIL STARTER HAS FROZEN” in the Operation | |
hard to pull |
|
|
| section of this manual. | |
Loss of traction | 1. | Drive belt is worn. | 1. | Check / replace drive belt. | |
drive / slowing of | 2. | Drive belt is off of pulley. | 2. | Check / reinstall drive belt. | |
drive speed | |||||
3. | Friction drive wheel is worn. | 3. | Contact an authorized service center/department. | ||
| |||||
|
|
|
|
| |
Loss of snow | 1. | Auger belt is off of pulley. | 1. | Check / reinstall auger belt. | |
discharge or | 2. | Auger belt is worn. | 2. | Check / replace auger belt. | |
slowing of snow | |||||
3. | Clogged discharge chute. | 3. | Clean snow chute. | ||
discharge | |||||
| 4. | Augers / impeller jammed. | 4. | Remove debris or foreign object from augers / impeller. | |
|
|
|
|
| |
Lights not On | 1. | Motor not running. | 1. | Start engine. | |
| 2. | Loose wire connection. | 2. | Check wire connections at engine and light. | |
| 3. | LED burnt out. | 3. | Replace LED light module. (Individual LEDs are not replaceable) | |
|
|
|
|
| |
21
