Tempstar Tempstar LT Tempstar NB
INSTALLATION/OPERATION Technical Manual
Tempstar S
Jackson MSC, LLC. P.O. BOX 1060 HWY E
Page
ONE Year Limited Parts & Labor Warranty
Manufacturers Warranty
Stop Pare Arret
Added new NSF rating
Released to production
Removed NSF Rating from steam heated unit
Nomenclature for the Models Covered in this Manual
Model Serial No Installation Date Service Rep. Name Phone No
Table of Contents
VI.C
VI.A
VII
Section Specification Information
Specification Information
Volts Ratings Amps Circuit
This model is wired in a wye configuration for the heaters
Tempstar S
Rinse Typical
Drain 1 1/2 NPT 8 12.4 cm 25 1/4 64.1 cm
Dimensions TEMPSTAR/NB/LT/S TOP Mounted Control BOX
Corner Installation
Table Dimensions
Section INSTALLATION/OPERATION Instructions
Installation Instructions
INSTALLATION/OPERATION Instructions
Side and from front to back before making any connections
Ground Lug
Operation Instructions
Detergent Control
False panel positioned in unit
False Panel Installation
Section Preventative Maintenance
Preventative Maintenance
Preventative Maintenance
Section Troubleshooting Section
Common Problems
Troubleshooting
Problem Water leaks at the wash pump
Problem Doors will not close completely
Problem Will not rinse during autocycle
Problem Dishes are not coming clean
Section Parts Section
Parts Section
TOP Mounted Control BOX Assembly with Universal Timer
Switch, 8 Button
Timer Bracket
Timer, Universal
Relay, 415V, 3PH, 5 Wire Only
Hood Assembly Bolted Single Support Design
10, 11
Cantilever ARM/DOOR Assemblies
19, 11
3e3d
Connector, Cantilever Arm
Yoke Assembly
Magnet, Reed Switch
Door, Right Side Complete Assembly
TUB Assembly
Pump Support Bracket Assembly
Rack Assembly
Connector, 1/2 90
Tub Weldment
Steam TUB Assembly
Connector, 1/2 90 Deg
Front Panel
Frame Assembly
Rinse Tank Assembly
Washer, 1/4 S/S Flat
Rinse Tank and Round Flange Heater Assembly
Nut, Hex, 1/4-20-18
Washer, 1/4 I.D
05700-002-08-62 05700-002-08-52
Coil Assembly
Incoming Steam Plumbing Assemblies
Wash Motors
Model Volts Phase Wash Motor Assembly
Other parts not shown
Motor & Pump Assembly
Wash HEATERS/RINSE Heaters
Model Volts Phase
Model Volts
Rinse Heaters Round Flanged Heater
Tempstar 208 04540-003-58-27 04540-003-58-28 230
Complete Assembly
Tempstar Incoming PLUMBING/OUTLET Plumbing Assembly
Complete assembly 05700-003-60-75
Tube Length Chart Item # Length Inches
Wprk KIT Option
Tempstar LT & Tempstar NB Incoming Plumbing Assembly
Complete Vacuum Breaker Assembly, 1/2 NPT
Solenoid Valve & 1/2 NPT Vacuum Breaker Repair Parts Kits
Complete 110 Volt Solenoid Valve Assembly, 1/2
Coil & Housing only
1811
Wash & Rinse ARM/MANIFOLD Assemblies
Rinse Injector Gasket Per machine 05330-111-42-81
Rinse Manifold Assembly
Bearing Assembly
Upper Manifold
Lockwasher,3/8
Transformer
Other Safety Door Interlock SDI components not shown
05925-111-64-18
380V Transformer 05950-111-64-17
False panel positioned in unit
Bearing Assembly, Wash Arm
Switch, Door, Magnetic Reed
Switch, Power Push Button
Pump & Motor Assembly, S/S
To Dishmachine Drain
Drain Quench Assembly
Tee, 1-1/2 x 1-1/2 x 1-1/2 Reducer, 1-1/2 to 1/2
To Cold Water Supply
Electrical Schematics For TOP Mount Units
Electrical Schematics
Electrical Schematics
Electrical Schematics
Electrical Schematics
Electrical Schematics
Electrical Schematics For Options
SDI Option
Exhaust FAN HOOKUP/DRAIN Quench Options
Section Jackson Maintenance Repair Centers
Alabama to Florida
Jackson Maintenance & Repair Centers
Florida to Maryland
Service CO
Maryland to NEW York
Jackson Service Compa
NEW York to Pennsylvania
Certified Service Center Rons Service
CENTER, INC
Rhode Island to Wisconsin
Wisconsin to WYOMING/INTERNATIONAL
Jackson Technical Manual Addendum