Tempstar S
INSTALLATION/OPERATION Technical Manual
Tempstar Tempstar LT Tempstar NB
Jackson MSC, LLC. P.O. BOX 1060 HWY E
Page
Manufacturers Warranty
ONE Year Limited Parts & Labor Warranty
Stop Pare Arret
Released to production
Added new NSF rating
Removed NSF Rating from steam heated unit
Model Serial No Installation Date Service Rep. Name Phone No
Nomenclature for the Models Covered in this Manual
Table of Contents
VI.A
VI.C
VII
Section Specification Information
Specification Information
Tempstar S
This model is wired in a wye configuration for the heaters
Volts Ratings Amps Circuit
Rinse Typical
Dimensions TEMPSTAR/NB/LT/S TOP Mounted Control BOX
Drain 1 1/2 NPT 8 12.4 cm 25 1/4 64.1 cm
Table Dimensions
Corner Installation
Section INSTALLATION/OPERATION Instructions
INSTALLATION/OPERATION Instructions
Installation Instructions
Side and from front to back before making any connections
Ground Lug
Operation Instructions
Detergent Control
False Panel Installation
False panel positioned in unit
Section Preventative Maintenance
Preventative Maintenance
Preventative Maintenance
Section Troubleshooting Section
Troubleshooting
Common Problems
Problem Will not rinse during autocycle
Problem Doors will not close completely
Problem Water leaks at the wash pump
Problem Dishes are not coming clean
Section Parts Section
TOP Mounted Control BOX Assembly with Universal Timer
Parts Section
Timer, Universal
Timer Bracket
Switch, 8 Button
Relay, 415V, 3PH, 5 Wire Only
Hood Assembly Bolted Single Support Design
19, 11
Cantilever ARM/DOOR Assemblies
10, 11
3e3d
Magnet, Reed Switch
Yoke Assembly
Connector, Cantilever Arm
Door, Right Side Complete Assembly
TUB Assembly
Connector, 1/2 90
Rack Assembly
Pump Support Bracket Assembly
Tub Weldment
Steam TUB Assembly
Connector, 1/2 90 Deg
Frame Assembly
Front Panel
Rinse Tank Assembly
Nut, Hex, 1/4-20-18
Rinse Tank and Round Flange Heater Assembly
Washer, 1/4 S/S Flat
Washer, 1/4 I.D
Coil Assembly
05700-002-08-62 05700-002-08-52
Incoming Steam Plumbing Assemblies
Model Volts Phase Wash Motor Assembly
Wash Motors
Motor & Pump Assembly
Other parts not shown
Model Volts Phase
Wash HEATERS/RINSE Heaters
Rinse Heaters Round Flanged Heater
Model Volts
Tempstar 208 04540-003-58-27 04540-003-58-28 230
Complete assembly 05700-003-60-75
Tempstar Incoming PLUMBING/OUTLET Plumbing Assembly
Complete Assembly
Tube Length Chart Item # Length Inches
Wprk KIT Option
Tempstar LT & Tempstar NB Incoming Plumbing Assembly
Complete 110 Volt Solenoid Valve Assembly, 1/2
Solenoid Valve & 1/2 NPT Vacuum Breaker Repair Parts Kits
Complete Vacuum Breaker Assembly, 1/2 NPT
Coil & Housing only
Wash & Rinse ARM/MANIFOLD Assemblies
1811
Rinse Injector Gasket Per machine 05330-111-42-81
Upper Manifold
Bearing Assembly
Rinse Manifold Assembly
Lockwasher,3/8
05925-111-64-18
Other Safety Door Interlock SDI components not shown
Transformer
380V Transformer 05950-111-64-17
False panel positioned in unit
Switch, Power Push Button
Switch, Door, Magnetic Reed
Bearing Assembly, Wash Arm
Pump & Motor Assembly, S/S
Tee, 1-1/2 x 1-1/2 x 1-1/2 Reducer, 1-1/2 to 1/2
Drain Quench Assembly
To Dishmachine Drain
To Cold Water Supply
Electrical Schematics For TOP Mount Units
Electrical Schematics
Electrical Schematics
Electrical Schematics
Electrical Schematics
Electrical Schematics
Electrical Schematics For Options
SDI Option
Exhaust FAN HOOKUP/DRAIN Quench Options
Section Jackson Maintenance Repair Centers
Jackson Maintenance & Repair Centers
Alabama to Florida
Service CO
Florida to Maryland
Jackson Service Compa
Maryland to NEW York
Certified Service Center Rons Service
NEW York to Pennsylvania
Rhode Island to Wisconsin
CENTER, INC
Wisconsin to WYOMING/INTERNATIONAL
Jackson Technical Manual Addendum