TROUBLESHOOTING
Disconnect the machine from the power source before making any repair.
Symptom | Cause | Solution |
| |
|
|
|
| |
Engine will not | No gasoline. | Fill gas tank. |
|
|
start. |
|
|
|
|
| Low oil level sensor activated. | Add oil. |
|
|
|
|
|
| |
| Choke is not in correct position. | Slide choke lever out to closed position. |
|
|
|
|
|
| |
| Engine throttle is not in | Slide the throttle lever up about 1/3 |
|
|
| correct position. | of the way toward the fast positon. |
| |
|
|
|
| |
| Pressure built up in the | Squeeze the trigger to |
|
|
| high pressure washer. | release the pressure. |
| |
|
|
|
| |
Unit does not reach | Diameter of garden hose | Replace with a 3/4 inch |
|
|
high pressure. | is too small. | garden hose. |
| |
|
|
|
| |
| Water supply is restrict- | Check garden hose for kinks, |
|
|
| ed. | leaks and blockage. |
| |
|
|
|
| |
| Not enough inlet water supply. | Open water source full force. |
|
|
|
|
|
| |
|
|
|
| 10 |
| Water inlet filter is | Remove filter and rinse out |
| |
|
|
| ||
| clogged. | in warm water. |
| |
|
|
|
| |
| Black detergent nozzle is | Remove black detergent nozzle |
|
|
| attached. | and attach a high pressure nozzle. |
| |
|
|
|
| |
Output pressure | Not enough inlet water | Turn water on full force. Check garden |
|
|
varies high and low. | supply. | hose for kinks, leaks or blockage. |
| |
|
|
|
| |
| Pump is sucking air. | Check that hoses and fittings are |
|
|
|
| air tight. Turn off machine and |
| |
|
| purge pump by squeezing trigger |
| |
|
| gun until a steady flow of water |
| |
|
| emerges through the nozzle. |
| |
|
|
|
| |
| Water inlet filter is | Remove filter and rinse out |
|
|
| clogged. | in warm water. |
| |
|
|
|
| |
| Discharge nozzle | Blow out or remove debris |
|
|
| is obstructed. | with a fine needle. |
| |
|
|
|
| |
| Calcified gun, hose | Run distilled vinegar through |
|
|
| or spray wand. | detergent suction tube. |
| |
|
|
|
|
|