Lennox Hearth ELDV-35NE, ELDV-35NM, ELDV-35PM, ELDV-40NE, ELDV-40NM, ELDV-40PM, ELDV-45NE, ELDV-45NM, ELDV-45PM ELDV3530 LOG PLACEMENT

NOTE: DIAGRAMS & ILLUSTRATIONS ARE NOT TO SCALE.

ELDV3530 LOG PLACEMENT

Log

Number Description

1 Log, Center

2 Log, Rear

3 Log, Front

4 Log, Left

5 Log, Right

Catalog Number for the entire

log set: H4656

Align holes at the bottom of log (1) over the

pins on the burner

Align holes at the bottom of log (2) over the pins

of the back bafﬂe.

Align the groove at the bottom of log (5) over the grate

and align the hole over the pin of log (4) as shown.

1Bafﬂe Pins Bafﬂe

Burner

Align groove at the bottom of log (3)

over the grate as shown.

Align the

holes at the

bottom of

log (4) over

the pins

on logs (1)

and (2).

Step 1

Step 2

Step 3

Step 4

Figure 46

Contents

Main INSTALLATION INSTRUCTIONS ELDV Direct-Vent Gas Fireplaces WARNING /AVERTISSEMENT / AVISO Page Page Figure 2 - Table 2 Figure 1 - Table 3 Table 4 NEW YORK CITY, NEW YORK (MEA) COLD CLIMATE INSULATION MANUFACTURED HOME REQUIREMENTS Figure 3 - Typical Locations LOCATION Side Elevation View Vertical Vent Termination Clearances Figure 4 - Multiple Terminations VENT TERMINATION CLEARANCES Vertical Vent Termination Clearances EXTERIOR HORIZONTAL VENT TERMINATION CLEARANCE REQUIREMENTS A X Figure 7 Figure 9 - Figure 10 - MINIMUM CLEARANCES TO COMBUSTIBLES Appliance And Vent Clearances Table 6 Figure 8 - Figure 11 DETAILED INSTALLATION STEPS Figure 12 - Nailing Flanges Step 1. FRAMING TYPICAL INSTALLATION SEQUENCE FIREPLACE AND FRAMING SPECIFICATIONS FRONT VIEW TOP VIEW Inches (millimeters) 1/2 FIREPLACE FRAMING SPECIFICATIONS Figure 14 - Corner Framing with Horizontal Termination Figure 15 - Route Gas Line Table 7 Proper Sizing of Gas Line Step 3. INSTALL THE VENT SYSTEM General Information Figure 16 Figure 17 TRAHCHTGNELNOITCESTNEV Table 8 u Firestop/Spacer SV4.5L6/12/24/36/48 Vent Sections 40 Max (12.2 M) 1" (25.4 mm) Minimum Clearance to Combustibles u use Firestop/Spacer SF4.5VF 6 Min (1.8 M) Figure 19 Figure 18 Figure 20 Figure 21 Figure 22 - Roof Framing Figure 24 Figure 23 u WARNING Under no circumstances, may sepa- rate sections of concentric exible vent pipe be joined together. u v AELBAT BELBAT Figure 27 - Top Vent - THREE ELBOWS VERTICAL VENT FIGURES/TABLES u Figure 28 Figure 30 Figure 29 - HORIZONTAL VENT FIGURES/TABLES Notes: Figure 31 v ELBATC WARNING Figure 32 HORIZONTAL VENT FIGURES / TABLES (CONTINUED) ELBATD V v H H1 Wall Firestop/Spacer (SV4.5HF) ELBATE Figure 33 HORIZONTAL VENT FIGURES / TABLES (CONTINUED) SECuRE FLEx Figure 34 Figure 35 Step 4. FIELD WIRING Figure 37 CAUTION (In Canada, the current CSA C22-1 Canadian Electrical Code). Figure 38 - BLOWER CONTROL CIRCUIT WIRING 120V, 60HZ, 1PH Step 5. WIRING - OPTIONAL FORCED AIR BLOWER KIT Figure 40 Step 6. CONNECTING GAS LINE Flex Line Connector WARNING Never use an open ame to check for leaks. Figure 43 Step 7. VERIFYING APPLIANCE OPERA- TION Figure 42 Figure 41 Page ELDV3530 LOG PLACEMENT ELDV4035 LOG PLACEMENT Page Step 9. REMOVING AND INSTALLING THE GLASS DOOR Figure 49 Step 10. BURNER ADJUSTMENTS Flame Appearance and sooting Do not operate appliance with the glass front removed, cracked or broken. Page Step 11. HOOD INSTALLATION Figure 54 Figure 53 FINISHING REQUIREMENTS - Wall Details See Page 5 for Cold Climate Insulation and Page 8 for Clearances APPOSITION DES MISES EN GARDE RELATIVES LA SCURIT DUTILISATION Figure A Figure B Figure C COLOCACIN DE ADVERTENCIAS DE SEGURIDAD EN OPERACIN ATTACHING SAFETY-IN-OPERATION WARNINGS SAFETY LABEL DIAGRAMS DIAGRAMAS DE ETIQUETAS DE SEGURIDAD INSTALLATION ACCESSORIES Listed Secure Vent Components Cat. No. Model Description Cat. # Model Description Listed Secure Vent Components Cat. # Model Description Listed Secure Flex Components INSTALLATION ACCESSORIES CONTINUED * Page Figure 55 Millivolt Appliances Figure 56 Figure 59 Figure 57 Figure 58

Lennox Hearth ELDV3530 LOG PLACEMENT

Models: ELDV-35NE ELDV-35NM ELDV-35PM ELDV-40NE ELDV-40NM ELDV-40PM ELDV-45NE ELDV-45NM ELDV-45PM