The appliance may be installed in an aftermarket permanently located, manufactured (mobile) home, where not prohibited by local codes. This appliance is only for use with the type of gas indicated on the rating plate. This appliance is not convertible for use with other gases, unless a certified kit is used.
| CONTENTS |
| |
Introduction………………………………. | 2 | Removing Burner………………………. | 10 |
Specifications and Dimensions…………… | 2 | Proper Burner Flame…………………… | 10 |
Safety Rules………………………………. | 3 | Optional Side Discharge Kit…………… | 14 |
Clearances………………………………… | 4, 5 | Terminal Block Wiring………………… | 13 |
Location…………………………………… | 6 | Manual Reset…………………………… | 13 |
Installation………………………………… | 6 | Maintenance Instructions………………. | 13 |
Operation…………………………………. | 7 | Trouble Shooting……………………….. 16,17 | |
Lighting Instructions……………………… | 8, 9 | Parts Drawing…………………………... | 18 |
Pilot Adjustment………………………….. | 10 | Parts List………………………………... 19,20 | |
|
| Warranty………………………………… | 22 |
INTRODUCTION
Read these installation and operating instructions carefully before you install or attempt to use this Direct Vent Counterflow Wall Furnace. If you do not understand any part of the instructions, consult local authorities, a qualified installer, service agency or the gas supplier. FAILURE TO READ OR UNDERSTAND THESE
INSTRUCTIONS CAN RESULT IN MALFUNCTION, INEFFICIENT OPERATION, PROPERTY DAMAGE, SERIOUS INJURY OR DEATH.
SPECIFICATIONS AND DIMENSIONS
Your Direct Vent Counterflow Wall Furnace is shipped in two cartons. One carton contains the furnace, thermostat, thermostat wire and insulated staples. The second carton will have the vent tube, air intake tube and vent cap assembly. After the furnace has been removed from the carton check the rating plate to verify that the model number is correct and that the wall furnace is equipped with the type gas you intend to use.
Model | Type | Type | Btu/Hr. | Gas |
| Blower |
|
| Approx. |
Number | Control Gas | Input | Inlet | Finished Dimensions | Speed | Amps | CFM | Ship. Wt. | |
24 VOLT SYSTEM WITH |
| ||||||||
24 Volt | Nat. | 40,000 | ½” | 1 | 1.95 | 320 | 128 Lbs. | ||
24 Volt | L.P. | 40,000 | ½” | 1 | 1.95 | 320 | 128 Lbs. | ||
24 Volt | Nat. | 62,500 | ½” | 2 | 3.05 | 440 | 142 Lbs. | ||
24 Volt | L.P. | 62,500 | ½” | 2 | 3.05 | 440 | 142 Lbs. | ||
24 VOLT SYSTEM WITH INTERMITTENT IGNITION (I.I.D.) | |||||||||
24 Volt | Nat. | 40,000 | ½” | 1 | 2.2 | 320 | 130 Lbs. | ||
24 Volt | L.P. | 40,000 | ½” | 1 | 2.25 | 320 | 130 Lbs. | ||
24 Volt | Nat. | 55,000 | ½” | 2 | 3.3 | 440 | 144 Lbs. | ||
24 Volt | L.P. | 55,000 | ½” | 2 | 3.35 | 440 | 144 Lbs. | ||
|
|
|
|
|
|
|
|
|
|
Page 2