Manuals / MartinLogan / Household Appliance / Indoor Fireplace

MartinLogan 33ISDG Replacement Parts List, Description, 33ISDN, 33ISDP, Common Parts, Accessories

Models: 33ISDG

1 40

Download 40 pages 62.92 Kb

Page 37

Image 37

REPLACEMENT PARTS LIST

REPLACEMENT PARTS ARE AVAILABLE THROUGH YOUR RETAILER.

Item	Description	Qty	33ISDN	33ISDP
Common Parts
1	Piezo Ignitor	1	14D0503	14D0503
2	Piezo Wire	1	00K0632	00K0632
3	Burner	1	70D0104	70D0104

Milli-Volt Control

4	Control Valve	1	14D0467	14D0468
5	Burner Injector	1	58D0051	58D0052
6	ODS Pilot Assembly	1	14D0473	14D0477
8A	Pilot/On/Off
	Knob Extension	1	37D0010	37D0010
8B	Hi/Lo Knob	1	37D0011	37D0011
7	On/Off Switch	1	32D0232	32D0232

Accessories

	Flex Connector		Flexcon18	All Models
	Wall Switch Kit		MVWS	All Models
	Wall Thermostat Kit		WT	All Models
	Hand Held Remote		RCB/RCM	All Models
			WMTD
	Hand Held Thermostat		RCST, RCT	All Models
	Remote		WWTD
	Thermostat Sensor Kit		TS	All Models
	Rock Wool Bag		TPB18-RW	All Models

23D8036

Page 37

Image 37

MartinLogan 33ISDG Replacement Parts List, Description, 33ISDN, 33ISDP, Common Parts, Milli-VoltControl, Accessories

Contents

Control Type Milli-Voltand T-Stat MODEL 33ISDG Natural Gas or Propane/LPGWHAT TO DO IF YOU SMELL GAS Do not try to light any applianceInstalling Canopy CONTENTSConnecting the Gas WarrantyINSTALLER IMPORTANT SAFETY INFORMATIONOWNER installed within the Commonwealth of This product must be installed by aof the burners clean may result in licensed plumber or gas ﬁtter whenOPERATION PRODUCT FEATURESOptional T-stat Sensor On/Off Switch Optional Face Plate Fireplace ScreenNATURAL GAS PRODUCT FEATURES AND SPECIFICATIONSMilli-Voltand T-StatPressure PROPANE/LPGGETTING STARTED WHAT YOU WILL NEED FOR INSTALLATIONMAKE SURE YOU HAVE RECEIVED ALL PARTS INSTALLING CANOPY GENERAL INSTALLATION INFORMATIONREMOVING SCREEN Figure 3 - Installing CanopyCODES Do not install the heater …American National Standards Institute, Inc National Fire Protection Association, IncGENERAL INSTALLATION INFORMATION WARNING WARNINGCLEARANCES AND HEIGHT REQUIREMENTS Accessory Face PlatesSmall Large21/2 CLEARANCES and HEIGHT REQUIREMENTS26 10 21/2Combustible Material 5 Non-combustible Material CLEARANCES and HEIGHT REQUIREMENTS23D8036 Figure 11 - Outer Wall Installation FIREPLACE FRAMINGFigure 12 - Inner Wall Installation Figure 14 - Corner InstallationFigure 15 - Removing Grate and Base Assembly SECURING HEATER TO FLOORFigure 16 - Securing Firebox to Floor or Hearth Figure 17 - Gas Connection CONNECTING THE GASAccess Door for Gas Line Cord Protector CONNECTING THE GASFigure 18 - Access Holes Manual Gas Shutoff Recommended OutletMILLIVOLT CONTROL Figure CHECKING GAS PRESSURETest Port “OUT” Figure 19 - Pressure Test Point LocationWall Switch On/Off Switch TH = TP = TP/TH = ELECTRICAL WIRING MILLI-VOLTSwitch ODS Pilot Millivolt Valve Spade Terminal SwitchELECTRICAL WIRING MILLI-VOLT CONNECTING REMOTE RECEIVER FigureFigure 21 - Installing Remote Receiver THESE INSTRUCTIONS SUPERCEDE THE SECTIONNever attempt to service heater while ELECTRICAL WIRING FANit is plugged in, operating, or hot Burns and/or electrical shock couldINSTALLING BLAZING OAK LOGS ON BURNER LOG PLACEMENTFigure 19 - Installing Right Base Log #1 Figure 20 - Installing Rear Log #2Left Base Log #3 Pins LOG PLACEMENTFigure 21 - Installing Left Base Log #3 PinsFigure 23 - Installing Left Top Log #5 LOG PLACEMENTLeft Top Log #5 Pin Left Base Log #3 Bottom Center PinDo not add additional rock wool Use only TPB-RWprovided with log setLOG PLACEMENT Figure 25 - Installing Right Front Log #6CHECKING THE PILOT FLAME FLAME APPEARANCETHERMOSTAT AND MILLI-VOLTCONTROL ThermocoupleOPERATING INSTRUCTIONS CHECKING THE BURNER FLAMEGlowing Embers Figure 33 - Correct Appearance of Rear FlamesOPERATING INSTRUCTIONS FOR YOUR SAFETY READ BEFORE LIGHTINGWHAT TO DO IF YOU SMELL GAS WARNING WARNINGLIGHTING INSTRUCTIONS MILLI-VOLT/THERMOSTATCONTROLTO TURN OFF GAS TO HEATER OPERATING INSTRUCTIONSBLOWER OPERATION MATCH LIGHTING INSTRUCTIONSOPERATING INSTRUCTIONS AND BLOWER OPERATION CLEANING AND SERVICING OBSERVED PROBLEM TROUBLESHOOTINGPOSSIBLE CAUSE REMEDYOBSERVED PROBLEM TROUBLESHOOTINGPOSSIBLE CAUSE REMEDY23D8036 ILLUSTRATED PARTS BREAKDOWNDescription REPLACEMENT PARTS LISTDIS33N/P OPTIONAL FACE PLATE6 5 3 8A 4 7 2 8B ILLUSTRATED PARTS BREAKDOWN23D8036 Accessories REPLACEMENT PARTS LISTDescription 33ISDNILLUSTRATED PARTS BREAKDOWN BLAZING OAK LOGS#6 #4 #5 #2 Description23D8036 FIVE YEAR WARRANTY LIMITED LIFETIME WARRANTY POLICYBASIC WARRANTY

33ISDN

33ISDP

Common Parts

Milli-Volt Control

Accessories