Manuals / MartinLogan / Household Appliance / Indoor Fireplace

MartinLogan 33ISDG Product Features, Operation, Optional Face Plate Fireplace Screen, Blower

Models: 33ISDG

1 40

Download 40 pages 62.92 Kb

Page 5

Image 5

PRODUCT FEATURES

Optional

Face Plate

Fireplace

Screen

Optional T-stat

Sensor

On/Off Switch

Piezo Ignitor

Control Knobs	Blower

Figure 1 - Unvented Gas Heater with Control Access Door Open

Your vent-free fireplace must be mounted to the floor or the fireplace hearth.

OPERATION

This unvented gas heater requires no outside venting and burns cleanly with high heating efficiency.

23D8036

Page 5

Image 5

MartinLogan 33ISDG Product Features, Operation, Optional Face Plate Fireplace Screen, Optional T-stat Sensor On/Off Switch

Contents

Control Type Milli-Voltand T-Stat MODEL 33ISDG Natural Gas or Propane/LPGWHAT TO DO IF YOU SMELL GAS Do not try to light any applianceInstalling Canopy CONTENTSConnecting the Gas WarrantyOWNER IMPORTANT SAFETY INFORMATIONINSTALLER installed within the Commonwealth of This product must be installed by aof the burners clean may result in licensed plumber or gas ﬁtter whenOPERATION PRODUCT FEATURESOptional T-stat Sensor On/Off Switch Optional Face Plate Fireplace ScreenNATURAL GAS PRODUCT FEATURES AND SPECIFICATIONSMilli-Voltand T-StatPressure PROPANE/LPGMAKE SURE YOU HAVE RECEIVED ALL PARTS WHAT YOU WILL NEED FOR INSTALLATIONGETTING STARTED INSTALLING CANOPY GENERAL INSTALLATION INFORMATIONREMOVING SCREEN Figure 3 - Installing CanopyCODES Do not install the heater …American National Standards Institute, Inc National Fire Protection Association, IncGENERAL INSTALLATION INFORMATION WARNING WARNINGCLEARANCES AND HEIGHT REQUIREMENTS Accessory Face PlatesSmall Large21/2 CLEARANCES and HEIGHT REQUIREMENTS26 10 21/223D8036 CLEARANCES and HEIGHT REQUIREMENTSCombustible Material 5 Non-combustible Material Figure 11 - Outer Wall Installation FIREPLACE FRAMINGFigure 12 - Inner Wall Installation Figure 14 - Corner InstallationFigure 16 - Securing Firebox to Floor or Hearth SECURING HEATER TO FLOORFigure 15 - Removing Grate and Base Assembly Figure 17 - Gas Connection CONNECTING THE GASAccess Door for Gas Line Cord Protector CONNECTING THE GASFigure 18 - Access Holes Manual Gas Shutoff Recommended OutletMILLIVOLT CONTROL Figure CHECKING GAS PRESSURETest Port “OUT” Figure 19 - Pressure Test Point LocationWall Switch On/Off Switch TH = TP = TP/TH = ELECTRICAL WIRING MILLI-VOLTSwitch ODS Pilot Millivolt Valve Spade Terminal SwitchELECTRICAL WIRING MILLI-VOLT CONNECTING REMOTE RECEIVER FigureFigure 21 - Installing Remote Receiver THESE INSTRUCTIONS SUPERCEDE THE SECTIONNever attempt to service heater while ELECTRICAL WIRING FANit is plugged in, operating, or hot Burns and/or electrical shock couldINSTALLING BLAZING OAK LOGS ON BURNER LOG PLACEMENTFigure 19 - Installing Right Base Log #1 Figure 20 - Installing Rear Log #2Left Base Log #3 Pins LOG PLACEMENTFigure 21 - Installing Left Base Log #3 PinsFigure 23 - Installing Left Top Log #5 LOG PLACEMENTLeft Top Log #5 Pin Left Base Log #3 Bottom Center PinDo not add additional rock wool Use only TPB-RWprovided with log setLOG PLACEMENT Figure 25 - Installing Right Front Log #6CHECKING THE PILOT FLAME FLAME APPEARANCETHERMOSTAT AND MILLI-VOLTCONTROL ThermocoupleOPERATING INSTRUCTIONS CHECKING THE BURNER FLAMEGlowing Embers Figure 33 - Correct Appearance of Rear FlamesOPERATING INSTRUCTIONS FOR YOUR SAFETY READ BEFORE LIGHTINGWHAT TO DO IF YOU SMELL GAS WARNING WARNINGLIGHTING INSTRUCTIONS MILLI-VOLT/THERMOSTATCONTROLTO TURN OFF GAS TO HEATER OPERATING INSTRUCTIONSOPERATING INSTRUCTIONS AND BLOWER OPERATION MATCH LIGHTING INSTRUCTIONSBLOWER OPERATION CLEANING AND SERVICING OBSERVED PROBLEM TROUBLESHOOTINGPOSSIBLE CAUSE REMEDYOBSERVED PROBLEM TROUBLESHOOTINGPOSSIBLE CAUSE REMEDY23D8036 ILLUSTRATED PARTS BREAKDOWNDescription REPLACEMENT PARTS LISTDIS33N/P OPTIONAL FACE PLATE23D8036 ILLUSTRATED PARTS BREAKDOWN6 5 3 8A 4 7 2 8B Accessories REPLACEMENT PARTS LISTDescription 33ISDNILLUSTRATED PARTS BREAKDOWN BLAZING OAK LOGS#6 #4 #5 #2 Description23D8036 BASIC WARRANTY LIMITED LIFETIME WARRANTY POLICYFIVE YEAR WARRANTY

PRODUCT FEATURES

Optional

Optional T-stat

Piezo Ignitor

Control Knobs

Blower

OPERATION