Test Setup, Transmit Tests | Maxon Telecom SM-2000 manual

		MAXON SM-2000 MOBILE
			TEST SETUP
		TEST SETUP
		TRANSMIT TESTS
	VARIABLE POWER	POWER
	SUPPLY WITH DC	POWER
	SUPPLY WITH DC	METER
	VOLT/CURRENT	METER	FREQUENCY
	VOLT/CURRENT	DEVIATION	FREQUENCY
	METER	DEVIATION	COUNTER
	METER	METER	COUNTER
		METER
		SM-2000
		OSCILLOSCOPE
	TEST BOX
	AUDIO	DUMMY LOAD	DISTORTION
	AUDIO	ATTENUATOR	ANALYZER
	GENERATOR	ATTENUATOR	ANALYZER
	GENERATOR

RECEIVER TESTS

COMMUNICATION

MONITOR OR

FM SIGNAL

GENERATOR

SINAD

METER

OSCILLOSCOPE

SM-2000

PAD

	VARIABLE	AC
	POWER
		VTVM
	SUPPLY

DISTORTION

ANALYZER

Page-21-

December 98

Image 25

Maxon Telecom SM-2000 service manual Test Setup, Transmit Tests

Contents

SM-2000 Page Maxon SM-2000 Mobile Table of Contents PCB Layouts Schematics and Block DiagramsSM-2000 Exploded View Transceiver Nominal Performance SpecificationsGeneral Band Operational BandwidthTransmitter Specfications SUB Audible Tones DCS TX Tone Modulation CharacteristicsReceiver Accessories RX Tone Demodulation CharacteristicsSubaudible tones CTCSS/DCS Reliability Analysis Introduction Check the carton carefully for the following items Unpacking Information General Description Description of Controls Description of Controls SM-2000 Rear Panel Digital Circuitry Theory of OperationCTCSS/DCS Decode Circuits CTCSS/DCS Encoder Circuit Eeprom PLL RF Section SM-2150/VHF TX VCO RX VCO Prescaler Out of Lock DetectorReceiver RF Amplifier Low Pass Filter Receiver Audio CircuitAudio Amplifier Noise Detect Circuit SQ Board UHF Transmitter RF Section SM-2450/UHFFrequency Synthesizer Circuit First Mixer Voltage Controlled Oscillator CircuitSecond Oscillator- Mixer- Limiter and FM Detector Squelch Noise Band Pass Filter Squelch Mute CircuitNoise Detector Speaker Audio Amplifier Transmit Tests Test Setup PLL Alignment SM-2150/VHF Alignment Procedure Receiver Alignment RF Discriminator Tuning Automatic Power Adjustment Squelch Adjustment Modulation Deviation Adjustment CTCSS/DCS Deviation Adjustment Alignment Points Diagram SM-2150/VHF SM-2450/UHF Alignment Procedure Page-28 December ∙ Note Release the PTT button when changing channels Page-30 December Alignment Points Diagram SM-2450/UHF Surface Mount Components Component ReplacementSurface Mount Removal Surface Mounted Integrated Circuit Replacement Surface Mount Component Replacement REF # Description Parts List Common to SM-2000 Digital Parts Common on Both VHF & UHF Digital Section REF # Description FRONT-END PCB Assembly Main Board Parts Band Chart Page-38 December Page-39 December Page-40 December Page-41 December SM-2450A UHF Band SM-2450C UHF Band SM-2450D UHF Band SM-2450E UHF Band Band Chart Page-44 December Page-45 December Page-46 December Page-47 December Component Pinout Page-49 December Page-50 December IC409 Voltage Charts SM-2150/VHF Page-52 December Transistor Voltage Chart Voltage Charts SM-2450/UHF IC404 Page-56 December Status Indications & Audible Tones Trouble Shooting Chart SM-2000 Page-58 December MMBV109 Replacement Module Schematics MA-4472 Microphone Schematic Page-61- December Page-62- December Page-63- December Page-64- December SM-2000 Control Head SW5 Page-66 December SM-2150/VHF Main Board Assy Front SM-2450/UHF Main Board Assy SM-2000 SM-2150/VHF Exploded View Parts List Intentionally Left Blank