Multiquip EM-70P, EM-70S manual

OPERATIONS MANUAL

Revision #1 (08/10/04)

THIS MANUAL MUST ACCOMPANY

THE EQUIPMENT AT ALL TIMES.

SERIES

MODEL EM-70S (STEEL)

MODEL EM-70P (PLASTIC)

PLASTER AND MORTAR MIXER

(GASOLINE ENGINE/ELECTRIC MOTOR)

Contents

Main Page HERE'S HOW TO GET HELP PLEASE HAVE THE MODEL AND SERIAL NUMBER ON-HAND WHEN CALLING To find the latest revision of this publication, visit our website at: www.multiquip.com EM-70 PLASTER/MORTAR MIXER TABLE OF CONTENTS MQ ESSICK EM-70 SERIES PLASTER/MORTAR MIXER When ordering parts, please supply the following information: Direct TOLL-FREE access to our Parts Department: Toll-free nationwide 800-427-1244 Toll-free F AX 800-6-P ARTS-7 Heres how to get help... EXT. FAX: EM-70 PLASTER/MORTAR MIXER SPECIFICATIONS SNOITACIFICEPSREXIM.1ELBAT NOTE 7 thgieHegrahcsiD).mc35(.ni12 evirDraeG/tleB-V noitcApmuDlaunaM )ROTOMCIRTCELE&ENIGNE(SNOITACIFICEPS.2ELBAT Page EM-70 PLASTER/MORTAR MIXER SAFETY MESSAGE ALERT SYMBOLS EM-70 PLASTER/MORTAR MIXER SAFETY MESSAGE ALERT SYMBOLS EM-70 PLASTER/MORTAR MIXER RULES FOR SAFE OPERATION hot! NEVER alcohol drugs inexperienced unauthorized HONDA Engine Owner's Manual ON/OFF fire department EM-70 PLASTER/MORTAR MIXER TOWING GUIDELINES mixer rolling, chocked blocks entire EM-70 PLASTER/MORTAR MIXER SAFETY CHAIN CONNECTION safety chain right completely empty. ALWAYS draw bar Page EM-70 PLASTER/MORTAR MIXER GENERAL INFORMATION sharp edges Honda wet areas only EM-70 PLASTER/MORTAR MIXER MAJOR COMPONENTS mixers with gasoline ALWAYS EM-70 PLASTER/MORTAR MIXER ENGINE COMPONENTS SLOW FAST EM-70 PLASTER/MORTAR MIXER ELECTRIC MOTOR electric motor Failure correct licensed electrician voltage change toggle switch plug Important!, Page Page EM-70 PLASTER/MORTAR MIXER INSPECTION all safety instructions mixer EM-70 PLASTER/MORTAR MIXER INSPECTION unleaded running hot! severe damage personal injury free flow of air EM-70 PLASTER/MORTAR MIXER START-UP PROCEDURE drum lock pin belt slip lever starter grip EM-70 PLASTER/MORTAR MIXER dump handle mix both hands left EM-70 PLASTER/MORTAR MIXER SHUT-DOWN PROCEDURES ON/OFF start/stop Start/Stop switch Serious Injury EM-70 PLASTER/MORTAR MIXER MAINTENANCE (ENGINE) ELUDEHCSECNANETNIAMENIGNE.8ELBAT warm EM-70 PLASTER/MORTAR MIXER MAINTENANCE (ENGINE) NEVER every month or when the drum becomes difficult to position Failure clamp face pivot points Disconnect the spark plug wire clamp face every 40 hours of operation pivot points remove power cord from AC power receptacle every 16 months. ALWAYS 250 hours of operation IMPORTANT! Avoid over-greasing. STNEMERIUQEREUQROTERIT.01ELBAT disconnect the spark plug wire remove power cord from AC power receptacle NEVER! Thoroughly clean dis-engaged EM-70 PLASTER/MORTAR MIXER TROUBLESHOOTING (ENGINE) and Mixer , Engine EM-70 PLASTER/MORTAR MIXER TROUBLESHOOTING (ENGINE) )DEUNITNOC(GNITOOHSELBUORTENIGNE.11ELBAT EM-70 PLASTER/MORTAR MIXER OPERATION MANUAL REV. #1 (008/10/04) PAGE 37 EM-70 PLASTER/MORTAR MIXER TROUBLESHOOTING (MIXER/ELECTRIC MOTOR) GNITOOHSELBUORTREXIM.21ELBAT GNITOOHSELBUORTROTOMCIRTCELE.31ELBAT Page Page HERE'S HOW TO GET HELP PLEASE HAVE THE MODEL AND SERIAL NUMBER ON-HAND WHEN CALLING OPERATIONS MANUAL