MT-62HS —TROUBLESHOOTING GUIDE
TABLE 4. ENGINE TROUBLESHOOTING
SYMPTOM | POSSIBLE PROBLEM | SOLUTION | |
|
|
| |
Difficult to start |
|
| |
|
|
| |
| Ignition plug being bridge? | Check ignition system. | |
|
|
| |
Fuel is available but spark plug | Carbon deposit at ignition? | Clean or replace ignition. | |
|
| ||
will not ignite. (Power available at | Short circuit due to defective | Replace insulators. | |
high tension cable). | |||
insulators? |
| ||
|
| ||
|
|
| |
| Improper spark gap? | Set spark plug gap to the correct gap. | |
|
|
| |
Fuel is available but spark plug | Short circuit at stop switch? | Check stop switch circuit. Replace stop switch if defective. | |
will not ignite. (Power NOT |
|
| |
|
| ||
available at high tension cable). | Ignition coil defective? | Replace ignition coil. | |
|
|
| |
| Muffler clogged with carbon | Clean or replace muffler. | |
| deposits? |
| |
|
|
| |
Fuel is available and spark plug | Mixed fuel quality is inadequate? | Check fuel to oil mixture. | |
|
| ||
ignites (compression normal). | Fuel in use inadequate (water, | Flush fuel sytem and replace with fresh fuel. | |
| |||
| dust)? |
| |
|
|
| |
| Air Cleaner clogged? | Clean or replace air cleaner. | |
|
|
| |
| Defective cylinder head gasket? | Tighten cylinder head bolts or replace head gasket. | |
Fuel is available and spark plug |
|
| |
Cylinder worn? | Replace cylinder. | ||
ignites (compression low ). | |||
|
| ||
| Spark plug loose? | Tighen spark plug. | |
|
|
| |
Operation not satisfactory |
|
| |
|
|
| |
| Air cleaner clogged? | Clean or replace air cleaner. | |
|
|
| |
Not enough power available | Air in fuel line? | Bleed (remove air) from fuel line. | |
|
| ||
(compression normal, no miss- | Fuel level in carbureator float |
| |
firing). | Adjust carbureator float | ||
chamber improper? | |||
|
| ||
|
|
| |
| Carbon deposits in cylinder? | Clean or replace cylinder | |
|
|
| |
| Ignition coil defective? | Flush fuel sytem and replace with fresh fuel. | |
Not enough power available |
|
| |
Ignition plug often shorts? | Replace ignition wires, clean ignition. | ||
(compression normal, miss- | |||
|
| ||
firing). | Fuel in use inadequate (water, | Flush fuel sytem and replace with fresh fuel. | |
| |||
| dust)? |
| |
|
|
| |
| Mixed fuel quality is inadequate? | Check fuel to oil mixture. | |
|
|
| |
| Excessive carbon depostion in | Clean or replace crankcase. | |
Engine overheats. | combustion chamber? |
| |
|
| ||
Exhaust or muffler clogged with | Clean or replace muffler. | ||
| |||
| carbon. |
| |
|
|
| |
| Spark plug heat value incorrect? | Replace spark plug with correct type spark plug. | |
|
|
|
PAGE 22 —
