Flame Check | New Buck Corporation FP-BR-10-ZC instruction

FLAME CHECK

FLAME CHECK

A periodic check of the flames should be made. The pilot flame should always be present when the gas logs are in operation.

FLAME: Propane (LP) should produce a flame that is 3"-4" above rear log. This flame should be yellow.

Natural gas should produce a flame that is 3"-4" above rear log. This flame should be mostly blue except for the top 1/2" which should be yellow.

FLAME

NATURAL

PROPANE

Page 24

Image 26

New Buck Corporation FP-BR-10-ZC manual Flame Check, Flame Natural Propane

Contents

Manufacturer NEW BUCK CORPORATION MODEL FP-BR-10-ZC VENT-FREEMarch P.O. Box 69 8000 Highway 226 SouthPage TABLE OF CONTENTS Page Page Page Page GAS LINES INSTALLATIONCHOOSING THE LOCATION FOR YOUR FIREPLACE DRAFTS 1/8” 11 5/8”1/8” 25 1/8” 24” 1 3/4” 25 1/8” Install the Firebox INSTALLING THE FIREBOXFIREPLACE CLEARANCES 17-3/4 SIDE WALL FINISHING YOUR FIREPLACECLEARANCES 7 MIN of Unit if mantel is 10 wide or more MANTEL PROFILES FOR ZERO CLEARANCE CABINETMUST BE FOLLOWED if mantel is 12 wide or less NOTE See page 18 for “Gas Pressure Check” MANTEL BASE 1/2 WOOD SCREWSTOP MANTEL REAR FLAME INSTALLATION AFTER-MARKETMOBILE HOMESGAS CONNECTION PRODUCING ADEQUATE VENTILATION DETERMINING FRESH-AIRFLOW FOR HEATER LOCATION VENTILATION AIR VENTILATION AIR FROM INSIDE BUILDING Outlet Air VENTILATION AIR FROM OUTDOORSVentilated Attic Outlet Air To Attic GAS PRESSURE CHECK Front View of Logs LOG PLACEMENTLogs are shipped secured in unit Page OPERATING INSTRUCTIONS Page Page Page FLAME CHECK FLAME NATURAL PROPANE MOTOR WIRING DIAGRAMPOWER CORD JUMPERTHERMOSTAT Page NOTE #PESBRO84 Blower MotorRating 120 volts/60HZ/0.54 Amps. 1 P.H IMPORTANT SAFEGUARDS CLEANING SOLUTION TROUBLESHOOTINGPROBLEM OBSERVED Depleted gas supply 6. Burner backfiring during WARNING above Important aboveWARNING above WARNING above REPAIR PARTS SERVICING PARTS LIST Maxitrol Valve BLOWN UP VIEW OF BURNER ASSEMBLY Page LIMITED WARRANTY MODEL FP-BR10-ZC NEW BUCK CORPORATION Page