READ AND FOLLOW SAFETY INSTRUCTIONS!
This is the safety alert symbol. When you see this symbol on your filter or in this manual, look for one of the following signal words and be alert
to the potential for personal injury.
warns about hazards that will cause death, serious personal in- jury, or major property damage if ignored.
warns about hazards that can cause death, serious personal in- jury, or major property damage if ignored.
warns about hazards that will or can cause minor personal injury or property damage if ignored.
NOTICE indicates special instructions not related to hazards.
Carefully read and follow all safety instructions in this manual and on equip- ment. Keep safety labels in good condition; replace if missing or damaged.
Incorrectly installed or tested equipment may fail, causing severe injury or property damage. Read and follow instructions
in owner's manual when installing and operating equipment. Have a trained pool professional perform all pressure tests.
1.Do not connect system to a high pressure or city water system.
2.Use equipment only in a pool or spa installation.
3.Trapped air in system can cause explosion. BE SURE all air is out of system before operating or testing equipment.
Before pressure testing, make the following safety checks:
•Check all clamps, bolts, lids, and system accessories before testing.
•Release all air in system before testing.
•Tighten
•Water pressure for test must be less than 25 PSI (172 kPa).
•Water Temperature for test must be less than 100o F. (38o C).
•Limit test to 24 hours. After test, visually check system to be sure it is ready for operation. Remove pump trap lid and retighten hand tight only.
NOTICE: These parameters apply to
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
| BEFORE WORKING | ||
|
|
|
|
|
|
|
|
| |||
|
|
|
|
|
|
| |||||
|
|
|
|
|
|
|
|
|
| ON FILTER: | |
|
|
|
|
|
|
|
|
|
| ||
|
|
|
|
|
|
|
|
|
|
| |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
| If filter clamps are | 1. | Stop pump. | |||||
|
|
|
| adjusted or removed |
|
|
| 2. | Open air release |
| |
|
|
|
| under pressure, |
|
|
|
| |||
|
|
|
|
|
|
|
| valve. |
| ||
|
|
|
| tank may explode, |
|
|
|
|
| ||
|
|
|
|
|
|
| 3. | Release all pressure |
| ||
|
|
|
| causing severe injury or |
|
|
|
| |||
|
|
|
| major property damage. |
|
|
|
| from system. |
| |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
| BEFORE WORKING | |
|
|
|
|
|
|
|
| ||||
|
|
|
|
|
|
|
|
|
| ON PUMP OR MOTOR | |
|
|
|
|
|
|
|
| ||||
|
|
|
|
|
|
|
|
|
|
| |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
| Filter pumps require | Disconnect power | |||||
|
|
|
|
| hazardous voltage |
|
|
| to motor at main |
| |
|
|
|
|
| which can shock, burn, |
|
|
| circuit breaker. |
| |
|
|
|
|
| or cause death. |
|
|
| Discharge motor |
| |
|
|
|
|
|
|
|
|
|
| capacitor to ground. |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
3
