Manuals / PVI Industries / Household Appliance / Water Heater

PVI Industries manual Alternate Gas Train Illustration, PV500-47C06/12

Models: PV500-47C

1 40

Download 40 pages 9.54 Kb

Page 29

Image 29

Gas Train Illustration

(Optional components may not be shown)

Alternate Gas Train Illustration

(Optional components may not be shown)

PV500-47C 06/12

Page 29

Image 29

PVI Industries manual Alternate Gas Train Illustration, PV500-47C06/12, Optional components may not be shown

Contents

PV500-47C06/12 INSTALLATION & MAINTENANCE MANUALTRICON WATER HEATER 2.Standard Features and Equipment TABLE OF CONTENTS 1.Safety Considerations4.Water Heater Installation 3.Product Descriptions15.Troubleshooting Guide 16.Replacement Parts 10.Operating and Safety Controls17.Periodic Maintenance 18.Recommended Maintenance SchedulePV500-47C06/12 1 SAFETY CONSIDERATIONSPRODUCT SAFETY INFORMATION HOMES FOR THE PHYSICALLY HANDICAPPED HOMES FOR THE MENTALLY HANDICAPPEDHOSPITALS AND NURSING HOMES ELDER CARE FACILITIES AND REST HOMES2.2Pressure Vessel 2 STANDARD FEATURES AND EQUIPMENT 2.1Performance2.3Heat Exchanger 2.4Codes And StandardsPV500-47C06/12 250 SERIESPV500-47C06/12 300 SERIES4.1Checking Equipment Before You Install 4 WATER HEATER INSTALLATION4.2Codes 4.3Electrical Requirements4.6Clearances To Combustible Surfaces 4.5Service Clearances5 GENERAL PIPING GUIDELINES 5.1Inlet and Outlet ConnectionsPV500-47C06/12 SINGLE WATER PIPINGPV500-47C06/12 TWO WATER HEATERS WITH REVERSE RETURN PIPING6CONDENSATE DRAIN, TRAP & DISPOSAL PV500-47C06/12 6.1Condensate Neutralization System optionalOptional Condensate Neutralization System 7GAS SUPPLY AND PIPING SINGLE UNIT INSTALLATION SUGGESTED PIPE SIZE7.1Gas Train and Controls Certification 7.2Gas Control TrainsNominal Iron MULTIPLE UNIT INSTALLATIONS GAS PIPING SIZE CHARTLength of Pipe in Straight Feet Inches8.1 Equipment Located In Confined Spaces 8COMBUSTION AND VENTILATION AIR∙All Air From Outdoors ∙All Air From Inside The BuildingDuct Fitting Equivalent Length Remote Air Duct SpecificationsDuct Pipe 6” DuctVolume cfm Venting Specifications9 VENTING 9.1Venting the TRICON Maximum Category IV Vent Equivalent Length9.4Combining Category IV Vents 9.3Vertical or Horizontal Vent TerminationConventional Venting Through the Wall Venting10.1Temperature and Pressure Relief Valve s 10OPERATING AND SAFETY CONTROLS10.2Operating Temperature Control 10.3High Water Temperature Limit Control11.1Principle Of Operation 11 TEMPTRAC ELECTRONIC CONTROLLER PANEL11.2Lower Led Readout 11.3Upper Led Readout11.6To Change The Setpoint 11.5To View The Setpoint11.7To Change Other Parameters PV500-47C06/12ALARM 11.8LED Display Alarm MessagesRESULTS OF ALARM CONDITION CAUSEPV500-47C06/12 13SEQUENCE OF OPERATION 1.Incoming 120VACFAULT MODE 7.Loss of Flame SignalLED INDICATION PV500-47C06/1214 INITIAL STARTUP 14.5Startup Procedure14.1Initial Startup Requirements 14.2Tools and Instrumentation RequiredPV500-47C06/12 13.Turn-offmain gas shutoff valve16.Turn-onmain gas shutoff valve PV500-47C06/12 Burner Combustion AdjustmentAlternate Gas Train Illustration Gas Train IllustrationPV500-47C06/12 Optional components may not be shownProblem 15 TROUBLESHOOTING GUIDEProbable Cause Corrective ActionPV500-47C06/12 REPLACEMENT PARTS16 REPLACEMENT PARTS PV500-47C06/12 16.1 Control PanelPV500-47C06/12 16.2Control Panel ComponentsOptional components may not be included PV500-47C06/12 16.3Burner AssemblyOptional components may or may not be shown BURNER ASSEMBLY COMPONENTS 16.4Burner Assembly ComponentsOptional components may not be included Item NoPV500-47C06/12 BURNER GAS TRAIN COMPONENTSContact factory for more information PV500-47C06/12 17PERIODIC MAINTENANCEPV500-47C06/12 i.Cycle unit and test to verify all safety and operating controls are properly functioning and the burner top plate flange is free of leaks1.Annual Maintenance 18RECOMMENDED MAINTENANCE SCHEDULE3.Monthly Maintenance 4.Daily MaintenancePV500-47C06/12