Manuals
/
PVI Industries
/
Household Appliance
/
Water Heater
PVI Industries
manual Replacement Parts, PV500-47C06/12
Models:
PV500-47C
1
31
40
40
Download
40 pages
9.54 Kb
28
29
30
31
32
33
34
35
<
>
Troubleshooting
Specs
Install
Error codes
Replacement Parts
Maintenance
Problem
16.3Burner Assembly
14.5Startup Procedure
Fault Mode
Page 31
Image 31
16 REPLACEMENT PARTS
REPLACEMENT
PARTS
31
PV500-47C
06/12
Page 30
Page 32
Page 31
Image 31
Page 30
Page 32
Contents
TRICON WATER HEATER
INSTALLATION & MAINTENANCE MANUAL
PV500-47C06/12
3.Product Descriptions
TABLE OF CONTENTS 1.Safety Considerations
2.Standard Features and Equipment
4.Water Heater Installation
18.Recommended Maintenance Schedule
10.Operating and Safety Controls
15.Troubleshooting Guide 16.Replacement Parts
17.Periodic Maintenance
PRODUCT SAFETY INFORMATION
1 SAFETY CONSIDERATIONS
PV500-47C06/12
ELDER CARE FACILITIES AND REST HOMES
HOMES FOR THE MENTALLY HANDICAPPED
HOMES FOR THE PHYSICALLY HANDICAPPED
HOSPITALS AND NURSING HOMES
2.4Codes And Standards
2 STANDARD FEATURES AND EQUIPMENT 2.1Performance
2.2Pressure Vessel
2.3Heat Exchanger
PV500-47C06/12
250 SERIES
PV500-47C06/12
300 SERIES
4.3Electrical Requirements
4 WATER HEATER INSTALLATION
4.1Checking Equipment Before You Install
4.2Codes
5.1Inlet and Outlet Connections
4.5Service Clearances
4.6Clearances To Combustible Surfaces
5 GENERAL PIPING GUIDELINES
PV500-47C06/12
SINGLE WATER PIPING
6CONDENSATE DRAIN, TRAP & DISPOSAL
TWO WATER HEATERS WITH REVERSE RETURN PIPING
PV500-47C06/12
Optional Condensate Neutralization System
6.1Condensate Neutralization System optional
PV500-47C06/12
7.2Gas Control Trains
SINGLE UNIT INSTALLATION SUGGESTED PIPE SIZE
7GAS SUPPLY AND PIPING
7.1Gas Train and Controls Certification
Inches
MULTIPLE UNIT INSTALLATIONS GAS PIPING SIZE CHART
Nominal Iron
Length of Pipe in Straight Feet
∙All Air From Inside The Building
8COMBUSTION AND VENTILATION AIR
8.1 Equipment Located In Confined Spaces
∙All Air From Outdoors
6” Duct
Remote Air Duct Specifications
Duct Fitting Equivalent Length
Duct Pipe
Maximum Category IV Vent Equivalent Length
Venting Specifications
Volume cfm
9 VENTING 9.1Venting the TRICON
Through the Wall Venting
9.3Vertical or Horizontal Vent Termination
9.4Combining Category IV Vents
Conventional Venting
10.3High Water Temperature Limit Control
10OPERATING AND SAFETY CONTROLS
10.1Temperature and Pressure Relief Valve s
10.2Operating Temperature Control
11.3Upper Led Readout
11 TEMPTRAC ELECTRONIC CONTROLLER PANEL
11.1Principle Of Operation
11.2Lower Led Readout
PV500-47C06/12
11.5To View The Setpoint
11.6To Change The Setpoint
11.7To Change Other Parameters
CAUSE
11.8LED Display Alarm Messages
ALARM
RESULTS OF ALARM CONDITION
PV500-47C06/12
13SEQUENCE OF OPERATION 1.Incoming 120VAC
PV500-47C06/12
7.Loss of Flame Signal
FAULT MODE
LED INDICATION
14.2Tools and Instrumentation Required
14.5Startup Procedure
14 INITIAL STARTUP
14.1Initial Startup Requirements
16.Turn-onmain gas shutoff valve
13.Turn-offmain gas shutoff valve
PV500-47C06/12
PV500-47C06/12
Burner Combustion Adjustment
Optional components may not be shown
Gas Train Illustration
Alternate Gas Train Illustration
PV500-47C06/12
Corrective Action
15 TROUBLESHOOTING GUIDE
Problem
Probable Cause
16 REPLACEMENT PARTS
REPLACEMENT PARTS
PV500-47C06/12
PV500-47C06/12
16.1 Control Panel
Optional components may not be included
16.2Control Panel Components
PV500-47C06/12
Optional components may or may not be shown
16.3Burner Assembly
PV500-47C06/12
Item No
16.4Burner Assembly Components
BURNER ASSEMBLY COMPONENTS
Optional components may not be included
Contact factory for more information
BURNER GAS TRAIN COMPONENTS
PV500-47C06/12
PV500-47C06/12
17PERIODIC MAINTENANCE
PV500-47C06/12
i.Cycle unit and test to verify all safety and operating controls are properly functioning and the burner top plate flange is free of leaks
4.Daily Maintenance
18RECOMMENDED MAINTENANCE SCHEDULE
1.Annual Maintenance
3.Monthly Maintenance
PV500-47C06/12