Manuals / Southbend / Kitchen Appliance / Convection Oven

Southbend Marathoner manual Installation

Models: Marathoner

1 76

Download 76 pages 39.36 Kb

Page 19

Image 19

4.Attach either the shelf or the two channel frames (depending on which option was ordered) as shown in the drawing below. Use the screws and four side rack clips provided to secure the shelf or channel frames to the rack guides.

MARATHONER GOLD & SILVERSTAR GAS CONVECTION OVENS

INSTALLATION

4.Attach either the shelf or the two channel frames (depending on which option was ordered) as shown in the drawing below. Use the screws and four side rack clips provided to secure the shelf or channel frames to the rack guides.

INSTALLATION

5.Attach the rack stop using two screws. Attach the top of the rack stop to the rear frame hanger, and the bottom of the rack stop to the bottom shelf or the rear channel frame, as shown in the following drawing.

OPERATOR’S MANUAL 1181887 REV 3

PAGE 19

Page 19

Image 19

Southbend Marathoner manual Installation

Contents

OPERATOR’S MANUAL SilverStar ModelsMarathoner Gold Models Marathoner Gold & SilverStar GAS CONVECTION OVENSSAFETY PRECAUTIONS WARNING FIRE HAZARD FOR YOUR SAFETYDANGER CAUTION NOTICEmanual carefully TABLE OF CONTENTSTable of Contents ELECTRICITY SUPPLY SPECIFICATIONSSPECIFICATIONS SPECIFICATIONSModel Number GAS SUPPLYSPECIFICATIONS SPECIFICATIONSSingle-Deck Ovens EXTERIOR DIMENSIONSSPECIFICATIONS SPECIFICATIONSSIDE VIEW SPECIFICATIONSDouble-Deck Ovens TOP VIEWSPECIFICATIONS MINIMUM CLEARANCESVENTILATION SPECIFICATIONSStep 1 Unpacking INSTALLATIONINSTALLATION INSTALLATIONINSTALLATION Step 2a Installation of Legs on Single-Deck OvensINSTALLATION PAGE Step 2b Installation of Legs on Double-Deck OvensINSTALLATION INSTALLATIONINSTALLATION Step 3 Installation of Restraint Only for Ovens with CastersINSTALLATION INSTALLATION Step 4 Stack Double-Deck Oven if necessaryINSTALLATION INSTALLATION INSTALLATIONOPERATOR ’S MANUAL 1181887 REV INSTALLATION INSTALLATIONFlue Stack INSTALLATION9. Install the flue stack as shown in the following diagram INSTALLATIONINSTALLATION Step 5 Install Down Draft Diverter if applicableInstallation of Down Draft Diverter INSTALLATIONINSTALLATION Step 6 Installation of Optional Open Rack StorageINSTALLATION INSTALLATION INSTALLATION4. Attach either the shelf or the two channel frames depending on which option was ordered as shown in the drawing below. Use the screws and four side rack clips provided to secure the shelf or channel frames to the rack guides INSTALLATION Step 7 Connect ElectricityELECTRIC GROUNDING INSTRUCTIONS INSTALLATIONINSTALLATION Step 9 Check the InstallationStep 8 Connect Gas Supply INSTALLATIONLIGHTING, RELIGHTING, AND SHUTDOWN INSTRUCTIONS OPERATIONOPERATION DANGER EXPLOSION HAZARDCook Timer Control Panel of STANDARD ModelsPower Switch Fan ModeOPERATION temperature of the ovenOperation of STANDARD Models OPERATIONCOOK Control Panel of CYCLE/COOK and HOLD ModelsOPERATION OPERATIONOPERATION Operation of CYCLE/COOK and HOLD ModelsOPERATION OPERATION OPERATIONOPERATION Control Panel of PROGRAMMABLE ModelsIndicates temperature setpoint. Flashes until setpoint is reached OPERATIONOPERATION Operation of Models with PROGRAMMABLE ControlsOPERATION OPERATION OPERATIONTEMP Control Panel of RACK TIMER ModelsOPERATION OPERATIONOPERATION Operation of RACK TIMER ModelsOPERATION OVERLOADING TIME & TEMPERATURECOOKING HINTS COOKING HINTSMeat and Fish COOKING PROBLEMS AND SOLUTIONSGUIDE TO TIMES AND TEMPERATURES then…Miscellaneous COOKING HINTSBaked Goods PotatoesMONTHLY CLEANING CLEANINGCLEANING DAILY CLEANINGCLEANING SEMI-ANNUAL CLEANINGCLEANING STAINLESS STEEL SURFACES CLEANINGADJUSTMENTS ADJUSTMENTSADJUSTMENTS ADJUSTING GAS PRESSURE REGULATORADJUSTMENTS ADJUSTING DOOR CHAIN MECHANISMADJUSTING DOOR SWITCH Door Switch and Door Chain AdjustmentADJUSTMENTS TEMPERATURE CONTROLLER Standard-Control Models OnlyFAHRENHEIT OR CELSIUS DISPLAY Cycle/Cook & Hold Models Only ADJUSTMENTSPERFORMANCE STANDARD TROUBLESHOOTINGINTERPRETING DISPLAYED ERROR CODES TROUBLESHOOTINGTROUBLESHOOTING TROUBLESHOOTING GUIDETable continues on next page CONTROL PANEL ACCESS AND SHUT-OFF SWITCH TROUBLESHOOTING GUIDE continuedAccessing Control Panel Components TROUBLESHOOTING BLOWER WHEEL REPLACEMENTTROUBLESHOOTING Electrical Schematic for 120 Volt Models with Standard ControlsOPERATOR ’S MANUAL 1181887 REV TROUBLESHOOTING Electrical Schematic for 208-240 Volt Models with Standard ControlsPAGE OPERATOR ’S MANUAL 1181887 REV TROUBLESHOOTINGPAGE TROUBLESHOOTINGOPERATOR ’S MANUAL 1181887 REV TROUBLESHOOTINGPAGE TROUBLESHOOTINGPARTS Index of Parts DiagramsPARTS PARTSPart Number Front Panel and Flue PartsPARTS PARTSPARTS Door PartsPARTS PARTS Door Chain Mechanism PartsPARTS PARTS Control Panel Parts for Models with Standard Controls SC ModelsPARTS PAGE PARTSControl Panel Parts for Models with Standard Controls SC Models PARTSPARTS Control Panel Parts for Cycle/Cook and Hold Models CCH ModelsPARTS PAGE PARTSControl Panel Parts for Cycle/Cook and Hold Models CCH Models PARTSPARTS Control Panel Parts for Models with Programmable Controls PC ModelsPARTS PARTS See parts list on previous pagePARTS Control Panel Parts for Models with Programmable Controls PC ModelsPARTS Control Panel Parts for Models with Rack Timer Controls RT ModelsPARTS PAGE Control Panel Parts for Models with Rack Timer Controls RT ModelsPARTS PARTSPARTS Internal Gas Supply PartsPARTS PARTS Burner Compartment PartsPARTS PARTS Oven Interior and Fan Motor PartsPARTS PARTS Oven Light PartsPARTS not shown on drawing Leg Parts for Single-Deck SilverStar ModelsPARTS PARTSPARTS Leg Parts for Single-Deck Marathoner Gold ModelsPARTS PARTS Storage Rack PartsPARTS PARTS Double-Deck Oven Stacking PartsPARTS PARTS Leg Parts for Double-Deck OvensPARTS PAGE MARATHONER GOLD & SILVERSTAR GAS CONVECTION OVENSOPERATOR’S MANUAL 1181887 REV MARATHONER GOLD & SILVERSTAR GAS CONVECTION OVENSPAGE MARATHONER GOLD & SILVERSTAR GAS CONVECTION OVENSOPERATOR’S MANUAL 1181887 REV MARATHONER GOLD & SILVERSTAR GAS CONVECTION OVENSMarathoner Gold & SilverStar GAS CONVECTION OVENS