FAN, Cooling, PLATE, Cooling FAN Setting | Stow STR36SP instruction

HONDA GX-670 — FLYWHEEL ASSY.

FLY WHEEL ASSY.
NO.	PART NO.	PART NAME	QTY.	REMARKS
1	19511ZJ1000	FAN, COOLING	1
2	19513ZJ1000	PLATE, COOLING FAN SETTING	1
3	28452ZJ1811	GRID, SCREEN P.T.O. (OPTIONAL)	1
4	28454ZJ1801	HOLDER, SCREEN GRID, OPTIONAL	1
5	31110ZJ1840	FLY WHEEL COMP.	1
6	90201ZG3000	NUT, FLANGE 20MM	1
7	90401ZG3000	WASHER 20MM	1
8	90741ZE2000	KEY, SPECIAL WOODRUFF 25 X 18	1
9	957010601200	BOLT, FLANGE 6 X 12 (OPTIONAL)	3
10	957010801600	BOLT, FLANGE 8 X 16	3

STR36SP- SERIES • RIDE-ON POWER TROWEL — OPERATION AND PARTS MANUAL — REV. #1 (09/16/11) — PAGE 101

Page 101

Image 101

Stow STR36SP FAN, Cooling, PLATE, Cooling FAN Setting, GRID, Screen P.T.O. Optional, FLY Wheel Comp, NUT, Flange 20MM

Contents

STR36SP Proposition 65WARNING Silicosis Warning SILCOSIS/RESPIRATORYWARNINGS Table of Contents Order via Fax Dealers Only Parts Ordering ProceduresBest Deal! Order via Internet Dealers Only Machine layout, location of components, checking of engine Training Checklist Daily PRE-OPERATION Checklist Daily PRE-OPERATION Checklist You can be Injured if you do not follow these directions STR36SP-SERIES Safety Message Alert Symbols Always wear approved eye and hearing protection STR36SP-SERIES Safety Message Alert SymbolsAlways wear approved respiratory protection Fatigue, illness or taking medicine Do not operate or service this equipment Lifting the Ride-On Trowel STR36SP-SERIES Rules for Safe OperationAlways keep the work area well organized Battery Towing Safety PrecautionsSTR36SP-SERIES Rules for Safe Operation Transporting Always know the location of the nearest first aid kit Maintenance SafetyEmergencies Machine Safety Decals STR36SP-SERIES Operation and Safety Decals TBD STR36SP-SERIES- Specifications Trowel STR36 Engine Specifications STR36SP-SERIES- Specifications Engine STR36SP-SERIES General Information STR36SP-SERIES Controls and Indicators Safety Stop Switch Shuts down engine when seat is empty STR36SP-SERIES Controls and Indicators Element STR36SP-SERIES Basic EngineMixture Flow of fuel Trowel Pre-Set Up Instructions STR36SP-SERIES NEW Machine Setup InstructionsControl Handle Assembly Seat Assembly Gearbox Oil Level Engine Oil Level Always check engine oil Before Each USE STR36SP-SERIES Operation Steering STR36SP-SERIES Operation STR36SP-SERIES Maintenance STR36SP-SERIES Maintenance  Have a 3/4 X 1 X 3-1/4 inch wooden block available Checking The Drive BeltRemoving the Drive Belt Reinstall the spare belt carrier and the drive belt guard STR36SP-SERIES- MaintenanceWooden Block CV-Joint Spare Drive Belt Replacement STR36SP-SERIES- Maintenance Torque Converter/Variable Pitch Pulley Drive Pulley Drive System Theory of Operation Clutch How It Works Figure Condition a  Engine IdlingBlade Pitch Matching Blade Pitch for Both Sets of Blades Stabilizer Ring Removal Trowel Arm adjustment Procedure Remove the trowel arm from the spider plate Trowel Arm RemovalTrowel Blade Removal Spider Plate Hex Head Bolt Zerk Fitting Checking Trowel Arm Straightness Trowel Arm Adjustment Re-Assembly Trowel Arm Adjustment Setup Decommissioning Trowel/Components Installing Pans Onto Finisher Blades STR36SP-SERIES -TROUBLESHOOTING Engine STR36SP-SERIES -TROUBLESHOOTING Engine Troubleshooting STR36SP-SERIES-TROUBLESHOOTING Trowel Troubleshooting STR36SP-SERIES-TROUBLESHOOTING Trowel STR36SP-SERIES Notes Xxxxx only Not Used on STR36SP-SERIES Explanation of Codes in Remarks Column STR36SP-SERIES Suggested Spare Parts Decals STR36SP-SERIES Decals DECAL, Powder Coated TBD DECAL, Stow DECAL, Spring SafetyDECAL, AL. Pitch RH TBD DECAL, AL. Pitch LH DECAL, Protective Clothing Pivot ASSY. RIGHT/LEFT STR36SP-SERIES Pivot ASSY. RIGHT/LEFT BAR, 1 Control Pivot WASHER, LOCK, 3/8 MEDRocker BLOCK, 1.0 Hole ARM, Pivot Right Hand Steering Handles ASSY, Left and Right STR36SP-SERIES Steering Handles ASSY. Left and Right ROD END, 3/8-24 Male RH GRIP, HandleHANDLE, Tube HANDLE, STEERING, Lower Steering Control ASSY., Left and Right STR36SP-SERIES Steering Control ASSY. Left and Right ROD END, 1/2-20 Male RH Assist ASSEMBLY, SteeringWASHER, Flat 1/2 SAE WASHER, Lock 3/8 MED Gearbox ASSY. Right Side STR36SP-SERIES Gearbox ASSY. Right Side 5031A SCREW, RHM 1/4- 20 X 1/2 0948 2006512981 20353 Gearbox ASSY. Left Side STR36SP-SERIES Gearbox ASSY. Left Side 10989 STUD, N10- 32 X 3/4 12907 1298210% 12583 SPACER, X 11D X 1.168L 11%+ 9045 12%+ 0232A Single Pitch Handle ASSY. Left and Right STR36SP-SERIES Single Pitch Handle ASSY. Left and Right Crank Knob Cable AssemblySpacer Crank Lever Drive Assy STR36SP-SERIES Drive Assy BOOT, CV Joint GASKET, CV Joint BootPLATE, Bearing Mount KEY, Woodruff #9 MUFFLER/BELT Assy STR36SP-SERIES MUFFLER/BELT Assy MUFFLER, 24 Honda ENGINE, Honda 24 HP GX670WASHER, Lock 5/16 Medium WASHER, Flat 5/16 USS Belt Guard Assy STR36SP-SERIES Belt Guard Assy Belt Guard Spider ASSY. Right STR36SP-SERIES Spider ASSY. Right Blade Assembly SCREW, Trowel AdjustmentPLATE, Wear Thrust Collar Wear Ring Spider ASSY. Left STR36SP-SERIES Spider ASSY. Left ARM, Trowel Left SPRING, LH Trowel ARM LeverLEVER, Trowel ARM Left Hand Yoke Assy STR36SP-SERIES -YOKE Assy PIN, Yoke Yoke Foot PEDALS/THROTTLE Assy STR36SP-SERIES Foot PEDALS/THROTTLE Assy SPRING, Throttle Return CABLE, Control 10-32 X 33 LongWASHER, Flat #10 SAE RISER, Left Foot Control Panel Assy STR36SP-SERIES Control Panel Assy Wire ASSEMBLY, 16 GA. X SWITCH,TOGGLE Electric #9061BOOT, Toggle Switch HARNESS, Wire Honda Rider FRAME/FUEL Assy STR36SP-SERIES FRAME/FUEL Assy TANK, Fuel Five Gallon Fuel Pump AssemblyFuel CAP/GAUGE BUSHING, Rubber Fuel Battery Assy STR36SP-SERIES Battery Assy BOLT, Battery Hold Down Bracket Battery HOLD- DownBOX, Battery GR UI BOOT, Terminal Seat Frame Assy STR36SP-SERIES Seat Frame Assy SWITCH, Kill COLE- HER #90036 CONNECTOR, RelayTERMINAL, Wire Pioneer Seat Plate AIR Cleaner Assy Honda GX-670 AIR Cleaner Assy SEAL, AIR Cleaner Housing CLIP, AIR CleanerSEAL, AIR Cleaner Cover PLATE, AIR Cleaner Setting Camshaft Assy Honda GX-670 Camshaft Assy SEAL, Valve Stem SPRING, Weight ReturnROD, Push ARM, Valve Rocker Carburetor Assy Honda GX-670 Carburetor Assy TUBE, Breather GASKET, AIR CleanerCLIP, Breather Tube Gasket SET Control 2 Assy Honda GX-670 Control Assy JOINT, ROD Lever ASSEMBLY,THROTTLESPRING, Starter ARM, Governor Control BOX Assy Honda GX-670 Control BOX Assy KEY Comp HOLDER, Stop Switch Wire BRACKET, Wire Harness Clip SUB- Wire Harness AssemblySCREW, Special 6 X CLIP, Wire Harness CASE, Control BRACKET, Case Mounting Crankcase Cover Assy Honda GX-670 Crankcase Cover Assy WEIGHT, Governor Cover ASSEMBLY, OIL PumpHOLDER, Governor Weight PIN, Governor Weight Crankshaft Assy Honda GX-670 Crankshaft Assy 90401ZJ1000 Crankshaft COMP., T-TYPE Cylinder Barrelassy Honda GX-670 Cylinder Barrel Assy SWITCH, OIL Pressure CLAMP, WireCOVER, Breather GASKET, Breather Cover Cylinder Head Assy Honda GX-670 Cylinder Head Assy GUIDE, Valve OS, Optional HANGER, EngineCLIP, Valve Guide GASKET, Cylinder Head FAN Cover Assy Honda GX-670 FAN Cover Assy PLATE, Right Side COVER, FAN *NH1* BlackPLATE, Left Side SHROUD, Right FLY Wheel Assy Honda GX-670 Flywheel Assy FAN, Cooling PLATE, Cooling FAN SettingGRID, Screen P.T.O. Optional FLY Wheel Comp Fuel Pump Assy Honda GX-670 Fuel Pump Assy STAY, Fuel Pump Pump ASSEMBLY, FuelTUBE, Fuel Tube B, Fuel Ignition Coil Assy Honda GX-670 Ignition Coil Assy GROMMET, Ignition Wire Coil Assembly R. IgnitionCoil ASSEMBLY, L.. Ignition Coil ASSEMBLY, Charge 12V/20A Labels Assy Honda GX-670 Labels Assy MARK, Emblem Honda GX-670 Labels Assy OIL Cooler Assy Honda GX-670 OIL Cooler Assy Cooler COMP., OIL Collar 12MMGRILLE, OIL Cooler Hose A, OIL Piston + Connecting ROD Assy Honda GX-670 Piston + Connecting ROD Assy BOLT, Connecting ROD 6 X ROD Assembly ConnectingRing SET, Piston STD Ring SET, Piston 0.75 Optional Starter Motor Assy Honda GX-670 Starter Motor Assy RING, Snap Denso Switch ASSEMBLY, MagnetCollar SET, Clutch Stop LEVER, Pinion Drive Payment Terms Terms and Conditions of Sale Parts STR36SP-SERIES-NOTES HERE’S HOW to GET Help

Stow STR36SP FAN, Cooling, PLATE, Cooling FAN Setting, GRID, Screen P.T.O. Optional, Washer 20MM

Models: STR36SP

HONDA GX-670 — FLYWHEEL ASSY.

FLY WHEEL ASSY.

REMARKS

FAN, COOLING

PLATE, COOLING FAN SETTING

GRID, SCREEN P.T.O. (OPTIONAL)

FLY WHEEL COMP.

NUT, FLANGE 20MM

WASHER 20MM

BOLT, FLANGE 6 X 12 (OPTIONAL)

BOLT, FLANGE 8 X 16