
Trouble |
| Possible Cause |
| Remedial Action |
|
|
|
|
|
|
|
|
|
|
Engine will not crank | 1. | Safety switch button not depressed | 1. | There are two switches in the starting |
|
|
|
| circuit of your unit. Make sure that the |
|
|
|
| actuator is fully depressing both switch |
|
|
|
| buttons. Brake pedal must be depressed |
|
|
|
| and blade engagement pedal disengaged. |
| 2. | Battery installed incorrectly | 2. | Install the battery with negative terminal |
|
|
|
| attached to the black ground wire. Attach |
|
|
|
| the positive terminal to the red wire which |
|
|
|
| goes to the solenoid. Charge the battery |
|
|
|
| fully before installation. |
| 3. | Battery dead or weak. | 3. | Check fluid level in battery. If fluid level is |
|
|
|
| low, fill to just below split rings with water. |
|
|
|
| Charge with 6 Amp. charger until fully |
|
|
|
| charged. If this does not work, replace |
|
|
|
| battery. |
| 4. | Blown fuse or circuit breaker | 4. | Replace fuse following instructions on |
|
|
|
| page 16. |
| 5. | Engine ground wire loose. | 5. | Make sure the black ground wire runs from |
|
|
|
| engine to frame or mounting bolt. |
Engine cranks but will | 1. | Throttle/choke not in starting position. | 1. | Check owner's guide for correct position |
not start |
|
|
| for throttle control/choke for starting. |
| 2. | No fuel to the carburetor | 2. | Gasoline tank empty. Fill with gasoline. |
| 3. | Fuel line or | 3. | Remove and clean fuel line. Replace filter if |
|
|
|
| necessary. |
| 4. | No spark to spark plug | 4. | Spark plug lead disconnected. Connect |
|
|
|
| lead. Hold spark plug lead away from |
|
|
|
| engine block about 1/8". Crank engine. |
|
|
|
| There should be a spark. If not, have |
|
|
|
| engine repaired at authorized engine |
|
|
|
| service dealer. |
| 5. | Faulty spark plug | 5. | To test, remove spark plug. Attach spark |
|
|
|
| plug lead to spark plug. Ground the spark |
|
|
|
| plug body against the engine block. Crank |
|
|
|
| the engine. The spark plug should fire at |
|
|
|
| the electrode. Replace if it does not. |
| 6. | Dirty air cleaner | 6. | If the air cleaner is dirty, the engine may |
|
|
|
| not start. Clean or replace as |
|
|
|
| recommended by the engine |
|
|
|
| manufacturer. |
Engine smokes | 1. | Engine oil has been overfilled | 1. | Check oil level. |
| 2. | Dipstick not seated or broken | 2. | Replace defective part. |
| 3. | Engine loses crankcase vacuum | 3. | Engine breather defective. Replace. |
For repairs beyond those listed in the
21