York B3CH 048 and 060 installation instructions SUNLINE 2000 SINGLE PACKAGE HEAT PUMPS, General

J￿

SUNLINE 2000

SINGLE PACKAGE HEAT PUMPS

INSTALLATION INSTRUCTION

Supersedes: 511.13-N1YI (900)/035-12984-000

035-12984-001-A-0204

MODELS B3CH 048 AND 060

(WORLD 50 HZ)

GENERAL

YORK Model BCH units are single package heat pumps designed for outdoor installation on a rooftop or a slab. Supplemental electric heaters are available as field-installed accessories. The units are manufactured under ISO 9002 Quality System Certification.

Units are completely assembled on rigid, permanently attached base rails. All piping, refrigerant charge, and electrical wiring is factory-installed and tested. The units require only electric power and duct connections at the point of installation.

The supplemental electric heaters have nickel-chrome elements and utilize single point power connection.

•530.18-N7.1V -Electric Heater Accessory

•530.18-N7.2V -Fuse Block Accessory

Renewal Parts:

•Refer to Parts Manual for complete listing of replacement parts on this equipment.

All forms referenced in this instruction may be ordered from:

Standard Register

Toll Free Tel: (405) 691-1126

Toll Free Fax: (405) 799-7746

INSPECTION

As soon as a unit is received, it should be inspected for possible damage during transit. If damage is evident, the extent of the damage should be noted on the carrier's freight bill. A separate request for inspection by the carrier's agent should be made in writing. See local distributor for additional information.

APPROVALS

These units are designed and manufactured as follows:

1.For use as a heat pump only unit or a heat pump unit with supplemental electric heat.

2.For outdoor installation only.

REFERENCE

Additional information on the design, installation, operation and service of this equipment is available in the following reference forms:

• 55.70-N1 -General Installation

•55.70-N2 -Pre-start & Post-start Check List

•530.18-N1.2V -Economizer Accessory

•530.18-N1.4V -Fixed Outdoor Air Damper Accessory

•530.18-N1.6V -Motorized Outdoor Air Damper Accy.

CAUTION

THIS PRODUCT MUST BE INSTALLED IN STRICT COMPLIANCE WITH THE ENCLOSED INSTALLATION INSTRUCTIONS AND ANY APPLICABLE LOCAL, STATE, AND NATIONAL CODES INCLUDING, BUT NOT LIMITED TO, BUILDING, ELECTRICAL, AND MECHANICAL CODES.

WARNING

INCORRECT INSTALLATION MAY CREATE A CONDITION WHERE THE OPERATION OF THE PRODUCT COULD CAUSE PERSONAL INJURY O R PRO PERTY DAM AG E .

Installer should pay particular attention to the words: NOTE, CAUTION and WARNING. Notes are intended to clarify or make the installation easier. Cautions are given to prevent equipment damage. Warnings are given to alert installer that personal injury and/or equipment damage may result if installation procedure is not handled properly.