Lenovo 1010, 992, 981, 1008 About this manual, Important Safety Information

Page 7

Chapter 1. About this manual

This Hardware Maintenance Manual contains information to help you solve problems that might occur in your server. It describes the diagnostic tools that come with the server, error codes and suggested actions, and instructions for replacing failing components.

Replaceable components are of three types:

Self-service customer replaceable unit (CRU): Replacement of self-service CRUs is your responsibility. If Lenovo® installs a self-service CRU at your request, you will be charged for the installation.

Optional-service customer replaceable unit: You may install an optional-service CRU yourself or request Lenovo to install it, at no additional charge, under the type of warranty service that is designated for the server.

Field replaceable unit (FRU): FRUs must be installed only by trained service technicians.

The most recent version of this document is available at http://www.lenovo.com/support.

Before servicing a Lenovo product, be sure to read the Safety Information. See “Important Safety Information” on page 1.

For information about the terms of the warranty and getting service and assistance, see the Warranty and Support Information document.

Important Safety Information

Be sure to read all caution and danger statements in this book before performing any of the instructions.

Veuillez lire toutes les consignes de type DANGER et ATTENTION du présent document avant d'exécuter les instructions.

Lesen Sie unbedingt alle Hinweise vom Typ "ACHTUNG" oder "VORSICHT" in dieser Dokumentation, bevor Sie irgendwelche Vorgänge durchführen

Leggere le istruzioni introdotte da ATTENZIONE e PERICOLO presenti nel manuale prima di eseguire una qualsiasi delle istruzioni

Certifique-se de ler todas as instruções de cuidado e perigo neste manual antes de executar qualquer uma das instruções

Es importante que lea todas las declaraciones de precaución y de peligro de este manual antes de seguir las instrucciones.

© Copyright Lenovo 2010,

1

Image 7
Contents ThinkServer Hardware Maintenance Manual Page ThinkServer Hardware Maintenance Manual Second Edition December Copyright Lenovo Contents Index About this manual Important Safety InformationTo Connect To Disconnect Safety statementsAbout this manual ≥ 18 kg 39.7 lb ≥ 32 kg 70.5 lb Important information about replacing RoHS compliant FRUs ThinkServerHardware Maintenance Manual General information Features and specificationsSecurity features Power supplySystem management features Input/Output I/O featuresEasyStartup SoftwareEasyManage ThinkServerHardware Maintenance Manual General Checkout Problem determination tipsThinkServerHardware Maintenance Manual Navigating through the diagnostics programs DiagnosticsPC-Doctor for DOS Creating a diagnostic disc Running the diagnostic program from a diagnostic discTest results Running testsHard disk drive boot error Troubleshooting tablesViewing the test log Beep Symptom FRU/Action Power Supply ProblemsBeep symptoms Error FRU/ActionPost Error Message Description/Action Post error codesLong and 9 short beeps Bios ROM error Continuos long beeps Dram memory errorHard Disk Install Failure EasyStartup problemsMessage/Symptom FRU/Action Miscellaneous error messagesDisplay/Monitor Second device hard disk First device networkUndetermined problems ThinkServerHardware Maintenance Manual Front view Locating Server Controls and connectorsRear view Connector Description System board connector locations System-board internal connectorsComponent locations Internal componentsReplacing FRUs Guidelines for trained service techniciansInspecting for unsafe conditions Handling static-sensitive devices Guidelines for servicing electrical equipmentServer components Removing the server cover Replacing FRUsRemoving the server cover Removing and reinstalling the front bezelRemoving the front bezel Installing or replacing a PCI cardOpening the PCI card latch Removing a PCI card Installing a PCI card Replacing the batteryRemoving the old battery Installing or replacing a memory moduleOpening the retaining clips Installing a memory module Installing or replacing the optical driveRemoving the optical drive Replacing the secondary hard disk drive Installing a secondary hard disk driveRemoving the secondary hard disk drive cage Installing the secondary hard disk drive Removing the screws for the power supply assembly Replacing the power supply assemblyReplacing the heat sink and fan assembly Replacing the microprocessor Removing the heat sink and fan assemblyThinkServerHardware Maintenance Manual Removing the microprocessor Replacing the system boardRemoving the system board Installing the socket cover Removing the primary hard disk drive Replacing the primary hard disk driveInstalling the hard disk drive into the bracket Installing the primary hard disk drive Replacing the front fan assembly Removing the front fan assembly Installing the front fan assembly Replacing the rear fan assemblyRemoving the rear fan assembly Installing the rear fan assembly Completing the parts replacementReinstalling the server cover Updating the server configurationMachine Type Parts Listing, TS200v Machine Types 0981, 0992, 1008,FRUs CTO Line Cords FRUs listed in the following tables are not illustratedWindows Server 2008 R2 Foundation 64-bit Windows Server 2008 R2 Standard 64-bit Ship GroupsWindows Small Business Server 2008 Standard w/ SP2 Microprocessor, Intel Celeron, 2.26G/2M-L2 models CTO Lenovo RDX drive bay models CTO All Models Lenovo RDX 320GB cartridge models CTO All Models 90Y1170 Microprocessor, Core i5-650 / 3.20GHz models CTO 15U 15Y Lenovo RDX drive bay models CTO All Models 256MB Nvidia FX380 2xDVI models CTO All models Windows Server 2008 R2 Foundation 64-bit 16G 16J 16L 16M 16S 16U 16Y Memory modules, DDR3 ECC PC3-10600 2GB Udimm 1333 models CTO 16U 16Y Line Cord Israel models CTO 16G ThinkServerHardware Maintenance Manual Viewing and changing settings Configuring the serverUsing the Setup Utility program Starting the Setup Utility programPassword considerations Using passwordsSata Controller USB SetupEnabling or disabling a device Selecting a startup deviceRAID Level Advanced settingsExiting from the Setup Utility program Configuring RAIDDeleting RAID volumes Creating RAID volumesUpdating system programs Using system programsUpdating flashing the Uefi from a disc Updating flashing the Uefi from your operating system Recovering from a POST/UEFI update failureUsing the ThinkServer EasyStartup program Installing ThinkServer EasyManage Agent ThinkServerHardware Maintenance Manual Appendix A. Notices Electronic emissions notices Export classification noticeTelevision output notice European conformance CE mark TrademarksEuropean Union EMC Directive conformance statement Industry Canada Class B emission compliance statementThinkServerHardware Maintenance Manual Canadian Department of Communications certification label Power cord noticePower cord part number Used in these countries and regions Waste electrical and electronic equipment Weee notices Disposing of disused lithium batteries from Lenovo computers European Union EU Weee statementAppendix A. Notices ThinkServerHardware Maintenance Manual CRU IndexRemoving Page Part Number 1P P/N