Char-Broil 463821909 manual #10-24 Wing Screw Qty, Center flat portion of hinge on bottom

Page 21

8

Attach side shelf with #10-24T-wing screw.

#10-24

T-Wing Screw

Qty: 4

9

Attach lower lid hinges to back of firebox using #10-24x1/2" machines screws, silicon washers and #10-24 flange nuts per hinge.

The center flat portion of the hinge should be at the bottom (see inset).

#10-24

Silicon Washer

 

Flange Nuts

Qty:8

#10-24 X ½”

Qty:4

 

Machine Screw

Lower Hinge

 

Qty:4

 

 

Center flat portion of hinge on bottom

21

Page 20 Page 22
Image 21
Page 20 Page 22
Contents Date Purchased Estimated assembly time 30 minutesThis Grill is for Outdoor USE only Table of ContentsCalifornia Proposition Installation Safety PrecautionsFirst Time Use TemperatureLava Rock / Briquettes Pre-Heating Your GrillDirect Cooking Food SafetyIndirect Cooking Rotisserie CookingUsda Recommended Safe Minimum Internal Temperatures General Cleaning Why Clean?Routine Care Storing Your GrillLP Liquefied Petroleum Gas USE and CareLP Cylinder Filling UL listed Overfill ProtectionFor your safety Connecting Regulator To The LP TankUseDo not household cleaning agents. Damage to gas LP Tank ExchangeConnection, do not use this regulator Leak Testing Valves, Hose and RegulatorTurn all grill control knobs to OFF Shelf fascia not Shown for clarityFor Safe Use Of Your Grill And To Avoid Serious Injury Safety TipsIgnitor Lighting SDo not lean over grill while lightingSideburner Match Lighting Sideburner Ignitor LightingBurner Flame Check Hose CheckCleaning the Burner Assembly Turn gas off at control knobs and LP cylinderCorrect burner-to-valve engagement Burner Tube Valve Disclaimer of Implied Warranties and Limitation of Remedies Limited Warranty Statement REVParts List DescriptionNot Pictured Parts Diagram Assembly Leg ExtenderCone side of wheel against leg Axle Bolt Qty.2 #10-24 X Machine Screw Qty.4 #10-24 Flange Nut Burner Assembly #10-24 x ½ Machine Screws Machine screws and silicon washers#10-24 Wing Screw Qty #10-24x2Screw #10-24x2 Valve Carriage Bolts #10-24 X#10-24 Wing Screw Qty Flange Nuts Qty8 #10-24 X ½ Qty4 Machine Screw Lower HingeCenter flat portion of hinge on bottom Page Cooking Grate Heat Tent Pivot Wire Swing Away LegTank Wire Emergencies Possible Cause Prevention/Solution TroubleshootingElectronic Ignition
Top Page Image Contents