Coleman 7700 LP Gas Series, 7700 Series manual 31-C, 32-A, 32-B

Page 31

31-C

DY (x2)

 

 

UO (x2)

TN (x2)

 

Left Mount Bracket

 

31-C. Attach the Left Support Bracket to the metal side panel using two Screws (TN), two Flat Washers (DY) and two Hex Nuts (UO).

NOTE

IF YOU ARE INSTALLING THE SHORT SPIT ROD FOR USE ON THE RIGHT BURNER, PROCEED WITH

STEP 32.

IF YOU ARE INSTALLING THE LONG SPIT ROD FOR USE ON THE RIGHT BURNER AND LEFT BURNER, SKIP

TO STEP 33.

Ö Install the Short Spit Rod into the Firebox.

Step

 

32

 

32-A

NOTE:

Slip Collar

Machined

 

 

Groove

Fork

Toward

 

Handle

 

Short Spit Rod

Handle

 

Set Collar

 

 

Fork

32-A. Loosely assemble the Rotisserie parts as shown in Figure 32-A. Do not tighten the thumbscrews until properly positioned in the grill.

32-B

 

 

Set Collar

Small Gap here

 

Center

 

Firebox

 

Wall

Slip Collar

32-B. Insert the Spit Rod into the Motor. Make sure the machined groove is toward the handle.

ÖPlace Slip Collar on Firebox Wall. Make sure the pointed tip of the Spit Rod stays in the Motor.

ÖPush Set Collar against the Slip Collar, provide a small gap to allow the Spit Rod to freely turn.

ÖTighten the thumbscrews on the Set Collar

and the Forks to hold in place.

31

Image 31
Contents Use, Care & Assembly Manual General Safety Information ContentsFollow these safety rules before each use General InstallationFuel Connections Other Than Portable L.P. Cylinders Electrical AttachmentsPortable L.P. Gas Barbecue Cylinders Transporting the Cylinder Cylinder SpecificationsGas Cylinder Hose and RegulatorTake these instructions to the L.P. gas dealer Filling and Purging Type Gas CylindersCGA-510 POL Assembly/Set up Center Base Hardware shown actual sizeRight Base Grill LabelSupport with one screw Right-Side-UpHandle Tighten all fastenersLocation Door Stop Hardware shown actual size VP x2 each magnet MagnetView of Grill from Rear CartRear Center Panel Rear Panel 10-A11-A 11-BFirebox Grill Cart Do Not Pinch Electrode Wires12-A 12-B13-B 13-A13-B FireboxFlange 14-A 14-B14-C Firebox Right Side Right Rear Panel15-D 15-A15-B 15-C16-B ALeft Fryer Assembly Left Rear Panel16-C 17-B 17-C 17-A17-D 18-C Fuel Hose from Fryer Assembly18-A 18-B19-B 19-AHooks Fryer Grease Pan 20-B 20-AFryer Heat Shield 21-B 21-A21-C 21-D Electrode Module Volt BatteryIgniter Button Wires 22-A23-B 23-A23-C Without Tool With Tool 24-A24-B 24-CRacks 25-A26-A Warming27-B 26-B26-C 27-A29-A 28-A29-B 31-B 30-A30-B 31-A32-A 31-C32-B Handle Long Spit Rod Slip Collar Set Collar Forkx4 32-C33-A 33-B34-C34-D 33-C34-A 34-B35-B 35-A35-C Rubber Plug Quick Disconnect Coupling Hose Connector Quick Disconnect CouplingRubber Cap Fixing a Fuel Leak Connecting Type 1 L.P. Gas CylindersLeak Testing How to Check for LeaksLighting Instructions Start-Up Check ListShutting Off the Grill Lighting Main Burners Fryer Burner Lighting24b Lighting Rotisserie BurnerGrilling Tips and Hints General Use and Correct Burner FlamesCase of Grease Fire Cooking Methods Cleaning the VenturiSide Fryer Cooking Methods Troubleshooting Cleaning and MaintenanceMoving and Storage Problem Flame behind control panel or control knob area For Your Additional SafetyProblem Grill too hot Problem Fire at any connectionColeman¨ Grill Warranty Registration Card Congratulations on Your NEW Coleman Grill Purchase Page Page Page Coleman Gas Barbecue Grill Limited Warranty Warranty