Weber 56219 manual Maintenance, Weber SPIDER/INSECT Screens, Main Burner Cleaning

Page 24

MAINTENANCE

CLEANING

mWARNING: Turn your Weber® gas barbecue off and wait for it to cool before cleaning.

mCAUTION: Do not clean your Flavorizer® bars or cooking grates in a self-cleaning oven.

For availability of replacement cooking grates and Flavorizer® bars contact the

Customer Service Representative in your area using the contact information on our website. Log onto www.weber.com®.

Outside surfaces - Use a warm soapy water solution to clean, then rinse with water..

mCAUTION: Do not use oven cleaner, abrasive cleansers (kitchen cleansers), cleaners that contain citrus products, or abrasive cleaning pads on barbecue or cart surfaces.

Slide out bottom tray - Remove excess grease, wash with warm soapy water, then rinse..

mCAUTION: Do not line the bottom tray with aluminum foil.

Flavorizer® bars and cooking grates - Clean with a suitable stainless steel bristle brush.. As needed, remove from grill and wash with warm soapy water, then rinse with water..

Catch pan - Disposable foil trays are available, or you can line the catch pan with aluminum foil.. To clean the catch pan, wash with warm soapy water, then rinse..

Thermometer - Wipe with warm soapy water; clean with plastic scrub ball..

Inside cooking module - Brush any debris off of burner tubes.. DO NOT ENLARGE BURNER PORTS (OPENINGS).. Wash inside of cooking box with warm soapy water and a water rinse..

Inside lid - While lid is warm, wipe inside with paper towel to prevent grease build-up.. Flaking built-up grease resembles paint flakes..

Stainless steel surfaces - Wash with a soft cloth and a soap and water solution.. Be careful to scrub with the grain direction of the stainless steel..

Do not use cleaners that contain acid, mineral spirits or xylene. Rinse well after cleaning.

Preserve your stainless steel - Your grill or its cabinet, lid, control panel and shelves may be made from stainless steel.. To keep the stainless steel looking its best is a simple matter.. Clean it with soap and water, rinse with clear water and wipe dry.. For stubborn particles, the use of a non-metallic brush can be used..

mIMPORTANT: Do not use a wire brush or abrasive cleaners on the stainless steel surfaces of your grill as this will cause scratches.

mIMPORTANT: When cleaning surfaces be sure to rub/wipe in the direction of the grain to preserve the look of your stainless steel. ◆

WEBER® SPIDER/INSECT SCREENS

Your Weber® gas barbecue, as well as any outdoor gas appliance, is a target for spiders and other insects.. They can nest in the venturi section (1) of the burner tubes.. This blocks the normal gas flow, and can cause the gas to flow back out of the combustion air opening.. This could result in a fire in and around the combustion air openings, under the control panel, causing serious damage to your barbecue..

The burner tube combustion air opening is fitted with a stainless steel screen (2) to prevent spiders and other insects access to the burner tubes through the combustion air openings..

We recommend that you inspect the Spider/Insect screens at least once a year. (See “ANNUAL MAINTENANCE” section) Also inspect and clean the the Spider/ Insect screens if any of the following symptoms should ever occur:

A)The smell of gas in conjunction with the burner flames appearing yellow and lazy.

B)Barbecue does not reach temperature..

C)Barbecue heats unevenly..

D)One or more of the burners do not ignite..

mDANGER

Failure to correct the above mentioned symptoms may result in a fire, which can cause serious bodily injury or death, and cause damage to property. ◆

1

2

MAIN BURNER CLEANING

TURN OFF THE GAS SUPPLY.

Remove the manifold (See “REPLACING MAIN BURNERS”).. Look inside each burner with a flashlight..

Clean the inside of the burners with a wire (a straightened-out coat hanger will work).. Check and clean the air shutter opening at the ends of the burners.. Check and clean the valve orifices at the base of the valves.. Use a steel bristle brush to clean outside of burners.. This is to make sure all the burner ports are fully open..

mCAUTION: Do not enlarge the burner ports when cleaning. ◆

24

Page 23 Page 25
Image 24
Page 23 Page 25
Contents GAS Grill Liquid Propane GAS Units only Table of Contents Exploded View Exploded View List Warranty Canadian Installation General InstructionsOperating Storage AND/OR Nonuse GAS Instructions Safe Handling Tips for Liquid Propane GAS CylindersLiquid Propane Cylinder Requirements Canadian Liquid Propane Cylinder RequirementsImportant LP Cylinder Information Leak Check PreparationCheck That All Burner Valves Are Off Liquid Propane CylinderConnect The Hose To The Cylinder Check for GAS Leaks Remove Control PanelReinstall Control Panel CheckLight Features Refilling the Liquid Propane CylinderWeber Grill OUT Handle Light Before Using the Grill Fuel LevelSlide OUT Grease Tray and Disposable Drip PAN Snap Ignition Operation Always open the lid before igniting the burnersMain Burner Ignition & Usage Main Burner IgnitionTo Extinguish Main Burner Snap IgnitionMain Burner Manual Ignition Grilling Tips & Helpful Hints Preheating Covered CookingDrippings And Grease Flavorizer SystemCooking Methods Direct CookingIndirect Cooking Side Burner Ignition & Usage Side Burner IgnitionOFF START/HI LOW Side Burner Manual Ignition Troubleshooting This is not a DefectSide Burner Troubleshooting Grill OUT Handle Light TroubleshootingMaintenance CleaningMain Burner Cleaning Weber SPIDER/INSECT ScreensReplacing Main Burners Side Burner Maintenance Annual Maintenance Inspection And Cleaning Of The Spider/Insect ScreensBurner Flame Pattern Memo Barbacoa DE GAS Advertencias Únicamente Unidades DE GAS Propano LicuadoÍndice GarantíaDiagrama DE Despiece Lista DEL Diagrama DE Despiece Garantía Instrucciones Generales Instalación CanadienseOperación DE LA Barbacoa Almacenaje Y/O SIN USOInstrucciones Sobre EL GAS Requisitos de los cilindros de propano licuadoInformación Importante Sobre EL Cilindro DE Propano Licuado Preparativos Para LA Búsqueda DE FugasEl cilindro de propano licuado Conecte la manguera al cilindro Detección DE Fugas DE GAS Retire el panel de controlVerifique Vuelva a instalar el panel de controlFunciones DE LUZ Cómo Recargar EL Cilindro DE Propano LicuadoLámpara DEL ASA Weber Grill OUT Antes DE Utilizar LA Barbacoa Nivel DE CombustibleSiempre abra la tapa antes encender los quemadores Encendido Y USO DEL Quemador Principal Encendido DEL Quemador PrincipalPara Apagar Encendido rápido del quemador principalEncendido Manual DEL Quemador Principal Advertencia No se incline sobre el asador abiertoConsejos Prácticos Para Asar PrecalentadoCocción cubierta Pringues y grasaMétodos DE Cocción Cocción DirectaCocción Indirecta Encendido Y USO DEL Quemador Lateral Encendido DEL Quemador LateralApagado Encendido Fuego Alto Fuego Bajo Encendido Manual DEL Quemador Lateral Resolución DE Problemas Problema Revisar SoluciónResolución DE Problemas CON EL Quemador Lateral Resolución DE Problemas DE LA LUZ DE ASA Grill OUTMantenimiento LimpiezaMallas Weber Contra Arañas E Insectos Limpieza DEL Quemador PrincipalReemplazo DE LOS Quemadores Principales Mantenimiento DEL Quemador Lateral ApagadoMantenimiento Anual Patrón de la llama del quemadorMemo Grill a GAZ Mises EN Garde Appareils a GAZ Propane UniquementTable DES Matieres GarantieVUE Eclatee Lise DE LA VUE Eclatee De la bouteilleGarantie Installation AU Canada GeneralitesUtilisation Stockage ET/OU InutilisationInstructions Concernant LE GAZ Exigences relatives à la bouteille de propane liquideInformations Importantes Relatives a LA Bouteille DE PL Preparation DE LA Detection DES FuitesVerifiez que toutes les valves des bruleurs sont fermees La bouteille de propane liquideConnexion du tuyau à la bouteille Retirer le panneau de commandes Detection DES Fuites DE GAZRemise en place du panneau de commande VérifiezFonctionnalites D’ECLAIRAGE Rechargement DE LA Bouteille DE Propane LiquideLampe DE Poignee Weber Grill OUT Avant D’UTILISER LE Grill Niveau DE CombustiblePLATEAU-EGOUTTOIR Amovible ET Egouttoir Jetable Ouvrez toujours le couvercle avant d’allumer les brûleurs Allumage & Utilisation DU Bruleur Principal Allumage DU Bruleur PrincipalPour Eteindre Allumage du bruleur du fumoir avec le boutonAllumage Manuel DU Bruleur Principal Astuces & Conseils Utiles Pour LES Grillades Cuisson couverteEcoulements de jus et de graisses Système FlavorizerMethodes DE Cuisson Cuisson DirecteCuisson Indirecte Allumage & Utilisation DU Bruleur Lateral Allumage DU Bruleur LateralArrêté MARCHE/ELEVE Faible Allumage Manuel DU Bruleur Lateral Resolution DES Problemes EleveIL NE S’AGIT PAS D’UN Defaut Resolution DES Problemes DU Bruleur Lateral Resolution DES Problemes DE LA Lampe DE Poignee Grill OUTNettoyage Grilles ANTI-ARAIGNEES/INSECTES WeberNettoyage DU Bruleur Principal Fermez L’ARRIVÉE DE GAZRemplacement DES Bruleurs Principaux Maintenance DU Bruleur Lateral ArrêtéMaintenance Annuelle Aspect des flammes du brûleurWEBER-STEPHEN Products CO
Top Page Image Contents