Invacare Wheelchair manual REMOVING/INSTALLING Shrouds Figure

Page 32

PROCEDURE 10

FWD WHEELCHAIRS

F

W D

W H E E L C H A I R S

REMOVING/INSTALLING SHROUDS (FIGURE 8)

Removing Front Shroud

1.Unclip the retaining strap securing the front shroud and battery box to the wheelchair.

2.Feed the retaining strap through the front shroud.

3.Remove the front shroud from the wheelchair.

Installing Front Shroud

1.Feed the retaining strap through the front shroud as shown in FIGURE 8.

2.Position the bottom of the front shroud between the battery box and the battery tray.

3.Clip the retaining strap together.

Removing Rear Shroud

1.Unclip the retaining strap securing the rear shroud and battery box to the wheelchair.

2.Feed the retaining strap through the rear shroud.

3.Remove the rear shroud from the wheelchair.

Installing Rear Shroud

1.Feed the retaining strap through the front shroud as shown in FIGURE 8.

3.Press down on the rear shroud until the two (2) clips secure the rear shroud to the two (2) side shrouds.

Removing Side Shrouds and Fillers

1.Remove the front shroud from the wheelchair. Refer to REMOVING/INSTALLING FRONT SHROUD in this procedure of the manual.

2.Remove the rear shroud from the wheelchair. Refer to REMOVING/INSTALLING REAR SHROUD in this procedure of the manual.

3.Perform one (1) of the following:

A.INTEGRATED SLING SEAT MODELS - Fold the wheelchair. Refer to TRANSPORTING EX- CEL in this procedure of the manual.

B.CAPTAIN'S SEAT MODELS- Remove the Captain's Seat from the wheelchair. Refer to REMOVING/INSTALLING CAPTAIN'S SEATin this procedure of the manual.

4.Remove the phillips screws, bolts, washers and lock- nuts that secure side shroud and filler to the wheel- chair frame. Refer to FIGURE 8 for phillips screw and washer locations.

5.Remove the side shroud and filler from the wheelchair.

6.Repeat STEPS 4-5for the opposite side of the wheel- chair, if necessary.

2. Clip the retaining strap together.

Locknut

Phillips Screws

 

Phillips Screws

 

Side Shroud

Retaining Strap

 

 

Rear Shroud

Wheelchair Frame

Washers

Battery Charger

Cover

Phillips Bolts

Front Shroud

Retaining Strap

 

Filler

 

Battery Box

Battery Tray

FIGURE 8 - REMOVING/INSTALLING SHROUDS - FWD WHEELCHAIRS

32

Page 31 Page 33
Image 32
Page 31 Page 33
Contents Excel Understanding this MANUAL. if YOU are Unable to R N I N GTable of Contents Specification S SpecificationsPower Procedure Repair or Service InformationGeneral Guidelines ElectricalSAFETY/HANDLING Wheelchairs Stability and BalanceCoping With Everyday Obstacles Tilting RWD Wheelchairs OnlyTransferring to and From Other Seats Percentage of Weight DistributionStairways Shows the motor mounting positions Functional Reach From a WheelchairReaching, Leaning, Bending and Bending Forward Reaching, Bending BackwardProcedure Safety INSPECTION/TROUBLESHOOTING Safety Inspection ChecklistTroubleshooting Mechanical Procedure 2SAFETY INSPECTION/TROUBLESHOOTING Troubleshooting ElectricalChecking Battery Charge Level Using Hydrometer to Check Battery Cells Lead Acid Figure Number of Floating Balls Will Vary According to ChargeINSTALLING/REMOVING Footrests Figure Adjusting Footrest HeightProcedure Front Riggings O N T I N G SRaising/Lowering Elevating Legrests INSTALLING/REMOVING Elevating Legrests FigureAdjusting Calfpads Adjusting Captains Seat Armrests Figure Procedure ArmsReplacing Seat Positioning Strap FigureReplacing Seat Upholstery Figure UPHOLSTERY/POSITIONING StrapMkiv Joystick MountingTube Adjustment Lock Repositioning Mkiv JoystickPreparing Mkiv Joystick for USE Figure C T R O N I C SReplacing Battery BOX Retaining Strap Retaining StrapT a I N I N G R a P RWD Wheelchairs FigureAdjusting Forks Figure S T E R SRemove the dust cover from the caster headtube Dust Cover Locknut Nylon Washer Caster Headtube ForkBatteries T T E R I E SConnecting Battery Cables Dual U1 or Dual Group 22 Battery BoxesBattery Cable Direct Mount MethodPositive + Battery Terminal/Post Battery Orange Battery Terminal Cap+ Battery BatteryBattery Clamp Battery Cable RED Battery Clamp Cover Positive + Battery T E R I E STransporting Excel E E L C H a I R SSeat Rails Unfolding/Folding Integrated Sling Seats FigureAdjusting FWD WheelchairsSecurely tighten with the locknut Push Pins Support in this procedure of the manualFlip Up Locknut Insert the rear socket bolt through the wheelchairREMOVING/INSTALLING Captains Seat Figure Limit SwitchArmrest Captains Joystick Seat MountingREMOVING/INSTALLING Shrouds Figure When to Charge Batteries Figure Installing Side Shrouds and FillersBattery Discharge Indicator BDI Description and Use of Battery ChargersCharging Batteries Figure A I R SBattery Charger Three Pronged Plug Front View From Battery Charger Port Joystick Battery BoxesRecommended Battery Types Cleaning Battery TerminalsINSTALLING/REMOVING Battery Boxes Figure Battery TrayFolding Battery Tray for Transport Figure Unfolding Battery Tray for Use FigureENGAGING/DISENGAGING Clutches Figures 15 Outside of Wheelchair Front of WheelchairUnfolding/Folding the Wheelchair Transporting Power 9000 FigureA I R RWD Wheelchairs Battery Charger Connector on Side of Wheelchair From Battery H a I R SClutches Figures 6 Battery Tray FigureENGAGING/DISENGAGING Using Wheel Locks Figure TabTowards rear WheelsMended psi on the side wall of tire Tighten the wheel lock to the wheelchair frameMotor Set Screw ExtensionHandle Rubber Tip If Equipped Page T E S Limited Warranty WarrantyRev D 1 5/00
Top Page Image Contents