CONTENTS
Getting Other Informations and Publications | ........ 3 | Start Up and Operation |
|
|
| General | 15 |
General Instructions |
| Topping Off System Charge | 15 |
Important | 4 | Safety Practices | 15 |
Shipping Damage | 4 | Start Up Notes | 15 |
General | 4 | Three Phase Scroll Compressor Start Up |
|
Field Installed Heater Packages (Optional) | 4 | Information | 16 |
|
| Sequence of Operation | 16 |
Installation |
| Indoor Blower Motor | 16 |
Location | 9 | Compressor Control Module | 16 & 17 |
Slab Mounting | 9 | Adjustments | 17 |
Typical Installations | 9 & 12 | Low Ambient Control | 17 |
Condensate Drain Trap | 12 |
|
|
Air Filters | 12 | Service and Troubleshooting |
|
Wiring – Main Power | 13 | Service Hints | 18 |
Wiring – 24V Low Voltage Control Circuit | 13 | Pressure Service Ports | 18 |
Transformer Taps | 13 | Refrigerant Charge | 18 |
Thermostats | 13 | Fan Blade Settings | 18 |
|
| Suction and Discharge Tube Brazing | 19 |
|
| Troubleshooting ECM Blower Motors | |
|
| Pressure Tables | 22 & 23 |
Figures |
|
| Tables |
|
|
Figure 1 | Unit Dimensions | 8 | Table 1 | Rated CFM & ESP | 4 |
Figure 2 | Slab Mounting at Ground Level | 10 | Table 2 | Electrical Specifications | 5 |
Figure 3 | Airflow and Service Access |
| Table 3 | Opt. Field Installed Heater Packages | 6 |
| Clearances | 10 | Table 4 | Opt. Field Installed Elec. Heater | 7 |
Figure 4 | Elevated Mounting Platform | 11 | Table 5 | Filter Requirements & Sizes | 12 |
Figure 5 | Condensate Drain Trap | 12 | Table 6 | Thermostat Wire Size | 13 |
Figure 6 | Low Voltage Wiring | 14 | Table 7 | Wall Thermostat and Subbase |
|
Figure 7 | Low Ambient Control Wiring | 17 |
| Combinations | 13 |
Figure 8 | Fan Blade Setting | 18 | Table 8 | Refrigerant Charge | 18 |
Figure 9 | Brazing Diagram | 19 | Table 9 | Fan Blade Setting Dimensions | 18 |
Figure 10 Control Disassembly | 21 | Table 10 | Indoor Blower Performance | 18 | |
Figure 11 | Winding Test | 21 | Table 11 | Pressure Table | 22 |
Figure 12 | Drip Loop | 21 | Table 12 | Pressure Table | 23 |
Manual | |
Page | 2 of 23 |