Emerson 2330MKII manual 3 HP

Page 3

BOOK 0958-B

SERIES 2330 MKII

SINGLE-PHASE

ADJUSTABLE-SPEED

DC MOTOR CONTROLLERS

(1/6 - 3 HP)

Control Techniques

3750 E Market Street

York, PA 17402-2798

USA

Tel 717.751.4200

Fax 717.751.4263

www.fincor.net

Image 3

Contents Book 0958-B Page 3 HP Book 0958-B Table of Contents List of Illustrations List of TablesBlank Following must be strictly adhered to at all times Section General Information Introduction General DescriptionModel Types Motor Selection Installation Guidelines Section InstallationDo not use solid wire Jumper J4 Position Motor Armature Current Rating Amperes Installing the ControllerInstall the controller cover, if used Controller Mounting Configurations Controller Mounting Dimensions Logic connection diagram, Run-Stop-Jog Switch Book 0958-B Book 0958-B Book 0958-B Signal Connection Diagram, Motor Speed Potentiometer Signal Connection Diagram, Tachometer Feedback Signal Connection Diagram, 4-20mA Interface Page Initial Startup Initial Potentiometer Settings DescriptionBook 0958-B Section Operation Power ON/OFF RUNStop Speed Control Torque ControlJOG Inoperative Motor ReverseLoad Monitor Current Loop TransducersBlank IR Compensation Section Maintenance and Repair GeneralAdjustment Instructions Acceleration DecelerationTachometer Feedback Setup Minimum SpeedCurrent Limit Corrective Action Troubleshooting Indication Possible CauseOne or more SCR‘s or Diode D1b Indication Possible Cause Corrective Action TroubleshootingTroubleshooting Indication Section Parts List Parts LIST, Series 2330 Mkii Controllers Fincor PartPart Blank 120% Section Ratings and SpecificationsOperating Conditions Operating Voltages and SignalsController Weights Performance CharacteristicsAdjustments SpecificationsShunt Field Data Tachometer Feedback Voltage Selection Section Drawings Functional Schematic, Series 2330MKII Series 2330MKII Control Board, 1/6 3HP Blank Index Maximum Speed Book 0958-B