Stow manual SHS62A CUT-OFF SAW Troubleshooting Engine

Page 27

SHS62A CUT-OFF SAW — TROUBLESHOOTING (ENGINE)

TABLE 4. TROUBLESHOOTING (ENGINE)

SYMPTOM

POSSIBLE CAUSE

SOLUTION

 

 

 

 

Spark plug bridging?

Check gap, insulation or

 

replace spark plug.

 

 

 

 

 

 

Carbon deposit on spark plug?

Clean or replace spark plug.

Difficult to start, "fuel is available, but no

 

 

Short circuit due to deficient spark plug

Check spark plug insulation,

SPARK at spark plug".

insulation?

replace if worn.

 

 

 

 

 

Improper spark plug gap?

Set to proper gap.

 

 

 

 

Ignition coil defective?

Replace ignition coil.

 

 

 

 

ON/OFF switch is shorted?

Check switch wiring, replace

 

switch.

 

 

 

 

 

Difficult to start, "fuel is available, and

Improper spark gap, points dirty?

Set correct spark gap and

SPARK is present at the spark plug".

 

clean points.

 

 

 

 

Spark plug wire broken or short circuiting?

Replace defective spark plug

 

wiring.

 

 

 

 

 

 

Wrong fuel type?

Flush fuel system, and replace

 

with correct type of fuel.

 

 

 

 

 

Difficult to start, "fuel is available, spark

Water or dust in fuel system?

Flush fuel system.

is present and compression is normal".

 

 

Air cleaner dirty?

Clean or replace air cleaner.

 

 

 

 

 

Choke Open?

Close Choke.

 

 

 

 

Suction/exhaust valve stuck or protruded?

Re-seat valves.

 

 

 

 

Piston ring and/or cylinder worn?

Replace piston rings and/or

 

piston.

Difficult to start, "fuel is available, spark

 

 

 

 

 

is present and compression is low".

Cylinder head and/or spark plug not

Torque cylinder head bolts and

 

tightened properly?

spark plug.

 

 

 

 

Head gasket and/or spark plug gasket

Replace head and/or spark plug

 

damaged?

gaskets.

 

 

 

 

Fuel not available in fuel tank (tank empy)?

Fill with correct type of fuel.

 

 

 

 

Fuel filter clogged?

Replace fuel filter.

No fuel present at the carburetor.

 

 

Fuel tank cap breather hole clogged?

Clean or replace fuel tank cap.

 

 

 

 

 

Air in fuel line?

Bleed fuel line.

 

 

 

SHS62A CUT-OFF SAW — OPERATION & PARTS MANUAL — REV. #0 (06/02/06) — PAGE 27

Page 26 Page 28
Image 27
Page 26 Page 28
Contents SideWinder Page Page SHS62A CUT-OFF SAW Table of Contents SHS62A CUT-OFF SAW Parts Ordering Procedures SHS62A CUT-OFF SAW Safety Message Alert Symbols SHS62A CUT-OFF SAW Safety Message Alert Symbols Always wear approved eye and hearing protectionRotating blade can cut and crush. Keep hands and feet clear SHS62A CUT-OFF SAW Rules for Safe Operation SHS62A CUT-OFF SAW Rules for Safe Operation General SafetyDiamond Blade Safety Saw Transportation SafetyNever use carbide-tipped or toothed type blades of any kind Always know the location of the nearest first aid kit SHS62A CUT-OFF SAW Rules for Safe OperationEngine Speed 10,000 DisplacementDimensions LxWxH Engine TypeMachine Operation And Safety Decals SHS62A CUT-OFF SAW Decal Placement10 9 8 7 6 SHS62A CUT-OFF SAW Controls & Components Blade shaft SHS62A CUT-OFF SAW Blade Installation InstructionsFasten the clamp to the Roller Bar Support Arm SHS62A CUT-OFF SAW Water KIT Installation InstructionsDiamond Blade SHS62A CUT-OFF SAW BladesStarting Place the engine ON/OFF switch in the on positionSHS62A CUT-OFF SAW Initial START-UP/OPERATION Fuel CheckShut-down SHS62A CUT-OFF SAW Initial START-UP/OPERATIONUntil the V-belt is completely slacked Belt Changing ProcedureKnob Cover GuardTensioning position SHS62A CUT-OFF SAW MaintenanceRe-install the guard V-belt should remain in tensionReversing the Cutting Arm Procedure Re-attach the cover guard Cam .The V-belt should remain in tensionAir/Fuel Filter Maintenance Procedures SHS62A CUT-OFF SAW Maintenance AIR/FUEL FilterSHS62A CUT-OFF SAW Troubleshooting Blade Troubleshooting Engine SHS62A CUT-OFF SAW Troubleshooting EngineSpark plug heat value improper? Troubleshooting EngineIncludes 1 ea SHS62A CUT-OFF SAW Filter KitsQTY. Column SHS62A CUT-OFF SAW Explanation of Parts Section RemarksNO. Column Part NO. ColumnTo 3 Units SHS62A CUT-OFF SAW Suggested Spare PartsSHS62A CUT-OFF SAW Muffler Assy Part Name SHS62A CUT-OFF SAW Recoil Start Assy HANDLE, Starter Rope SHS62A CUT-OFF SAW Crankcase Assy Plate SHS62A CUT-OFF SAW V-BELT Cover Clutch Side Assy SHS62A CUT-OFF SAW V-BELT Cover Clutch Side Assy SHS62A CUT-OFF SAW V-BELT Cover Pulley /BLADE Guard Part Name QTY SHS62A CUT-OFF SAW Fuel Tank Assy Part Name QTY Remarks SHS62A CUT-OFF SAW Lifting Handle and Roller Assy SHS62A CUT-OFF SAW Lifting Handle and Roller Assy SHS62A CUT-OFF SAW -THROTTLE Linkage Assy Spring SHS62A CUT-OFF SAW Flywheel Cover Assy WASHER, Flat SHS62A CUT-OFF SAW Flywheel Assy Pawl SET SHS62A CUT-OFF SAW Ignition Coil Assy Spring Spark Plug SHS62A CUT-OFF SAW AIR Filter Assy FLANGE, PRE- FILTER, CAP SHS62A CUT-OFF SAW Carburetor Mounting Assy Carburetor Mounting Assy SHS62A CUT-OFF SAW Carburetor Assy Throttle Shaft SHS62A CUT-OFF SAW Crankshaft / Piston Assy SHS62A CUT-OFF SAW Crankshaft and Piston Assy SHS62A CUT-OFF SAW Water KIT Assy VALVE, SHUT-OFF SHS62A CUT-OFF SAW Tools 00325 HS4191240SHS62A CUT-OFF SAW Recommended Diamond Blades Recommended Diamond Blades For Your Side Winder SawTerms and Conditions of Sale Parts Terms and Conditions of SaleHeres HOW to GET Help
Top Page Image Contents