Monessen Hearth VWF36, VWF30 manual LOG Placement, Filling the Burner PAN, VWF18 Massive OAK Logs

Page 12

LOG PLACEMENT

FILLING THE BURNER PAN

Fill the burner pan with vermiculite to the bottom of the rear log and sloped to the front edge of the burner pan. Excess ver- miculite can spill forward or to the side of the burner pan. Do not overfill the propane model. Do not cover the pilot (if SPK or MVVK is installed) with vermiculite or rock wool (embers).

PLACEMENT OF GLOWING EMBERS (ROCK WOOL)

The Wildfire flame appearance can vary due to differences in draft and fireplace configurations and ember placement. After installing rear (#1) and front logs (#2 and #3), cover the entire top surface of the vermiculite in the burner pan with the rock wool supplied with unit. Tear the rock wool into pieces approximately 1/2" in size (roughly the size of a nickel) and cover the burner evenly. Do no use more rock wool than the amount supplied with the unit. To enhance the appearance of the Wildfire flame, it is recommended to form a mound of rock wool in the center of the burner, 2" to 3" high, visible through the two front logs.

PLACEMENT OF DECORATIVE VOLCANIC ROCK

Sprinkle volcanic rock in front of front glowing embers and to both sides.

DO NOT SPRINKLE ON BURNERS, EMBER BED, PILOT OR LOGS.

IMPORTANT: Do not handle logs with your bare hands! Always wear gloves to prevent skin irritation from ceramic ﬁbers. After handling logs, wash your hands gently with soap and water to remove any traces of ﬁbers.

VWF18 MASSIVE OAK LOGS

1.Slide shield plate down back of burner pan. See Figure 11.

2.Center rear log #1 on grate bars and flush with rear of the grate. See Figure 12.

Rear Log (#1)

Shield

Plate

Burner

Pan

Figure 11 - Sliding Shield Plate Down Back of	Figure 12 - Centering Rear Log (#1) on Grate Bars
Burner Pan	Continued
	Continued

12

27D8520

Image 12

Contents Models VWF18 VWF24 VWF30 VWF36 Read and Save These InstructionsContents Important Safety Information InstallerOwner Safety Information Product SpecificationsMinimum Hearth Dimensions Getting Started Make Sure YOU have Received ALL PartsMinimum Opening Area of Chimney Damper for Venting Minimum Chimney Height and Flue OpeningPlacement in a Fireplace with a Restrictive Barrier Height of Restriction Minimum Depth of Fireplace/FireboxInstallation Damper Stop InstallationBefore Installing the Appliance Installing Valve Cover Covers must be installed prior toOperation to prevent overheating Grate bar must not touch the valveWiring MILLI-VOLT Keep wiring away from heatSource and hot surfaces Connecting the GAS PipePressure Test Point Location LOG Placement Placement of Glowing Embers Rock WoolPlacement of Decorative Volcanic Rock Filling the Burner PANPlacing Front Left Log #2 on Grate VWF24 Massive OAK Logs Sliding Shield Plate Down BackVWF30 Massive OAK Logs Centering Rear Log #1 on Grate BarsInstalling Right Middle Log #5 VWF30 Massive OAK LogsVWF36 Massive OAK Logs Sliding Shield Plate Down Back of Burner PanInstalling Right Side Middle Log #7 VWF36 Massive OAK LogsVWF18 American OAK Logs Placing Back Log #2 on GrateVWF24 American OAK Logs Placing Back Log #2 on Grate BarsVWF30 American OAK Logs Placing Front Log #2 on Front GrateVWF30 American OAK Logs Placing Left Crossover Log #7Notch Grate Prong Models VWF24 B 6 LogsModels VWF24/18 Split River OAK Placing Rear Log #1 on Back of GrateModels VWF24/18 Split River OAK Resting Top Right Log #4 onModels VWF30/24 Split River OAK Resting Top Right Log #4 on Bottom Left LogModels VWF30/24 Split River OAK Models VWF36/30 Split River OAK Sliding Shield Plate DownModels VWF36/30 Split River OAK Resting Center Top Log #7 BottomModels VWF18 Split Pine Placing Left Front Log #1A on GrateInstalling Right Log #6 Models VWF18 Split PineModels VWF24 Split Pine Placing Side Support Log #2 on Top Left of Log #1AInstalling Top Center Log #7 Models VWF24 Split PineModels VWF30 Split Pine Placing Side Support Log #2 on TopInstalling Right Middle Log #7 Models VWF30 Split PineModel VWF24/18WP Weathered Pine LOG Placing Rear Log #1 on Back GrateModel VWF24/18WP Weathered Pine LOG Placing Top Left Log #5 behind Rear LogModel VWF30/24WP Weathered Pine LOG Model VWF30/24WP Weathered Pine LOG Placing Top Center Log #7 on Rear LogModel VWF36/30WP Weathered Pine LOG Straddling V of Bottom Left LogModel VWF36/30WP Weathered Pine LOG Safety Instruction for Manual Control SPK Operating InstructionsWhat to do if YOU Smell GAS MILLI-VOLT Control Lighting Instructions Flame Appearance Checking Burner FlamesPilot Flame Appearance Fireplace Draft Test Fireplace Draft Test MethodRemote Control Receiver Replacement Cleaning and ServicingReplacement Parts AssemblyMassive OAK Logs VWF18MO VWF24MO VWF30MOAmerican OAK Logs Birch LogsSplit River OAK Logs VWF24/18SRO VWF30/24SRO VWF36/30SROSplit Pine Logs VWF18SPA and VWF24SPAWeathered Pine Logs Description Qty VWF24/18WPCarbon Monoxide Detector Requirements Special Requirements 27D8520 Lifetime Warranty Five Year Warranty