Mitsubishi Electronics Explore Parts R01-35J-130, R01-43E-126, T7W-30J-762 for PCA-A24GA

Page 31

12 PARTS LIST (non-RoHS compliant)

FAN AND FUNCTIONAL PARTS

PCA-A24GA PCA-A30GA

PCA-A36GA PCA-A42GA

16

1

15

2

				3

				4

				5
				5																		14



																				13

																		12

																11
						6

								7
																10

										8

												9



														Q'ty/set							Remarks	Wiring		Recom-
No.	Parts No.				Parts Name					Specifications				PCA-A							Remarks	Wiring		Recom-
No.	Parts No.				Parts Name					Specifications				24/30	36/42					(Drawing No.)		Diagram		mended
														24/30	36/42					(Drawing No.)		Symbol		Q'ty
	R01	29J	130												GA
1	R01	29J	130	MOTOR LEG										1
1	R01	35J	130	MOTOR LEG											1
2	R01	43E	126	PIECE(MOTOR)										1	1
3	T7W	30J	762	FAN MOTOR						D09C4P70MS				1								MF
3	T7W	E14	762	FAN MOTOR						D10C4P90MS					1							MF
4	R01	700	116	SHAFT JOINT										1	1
5	R01	E17	114	SIROCCO FAN										2
5	R01	E19	114	SIROCCO FAN											2
6	R01	E26	202	ROOM TEMPERATURE THERMISTOR										1	1							TH1
7	R01	29J	100	SHAFT										1	1
8	R01	E00	103	SLEEVE BEARING										1	1
9	R01	29J	145	BEARING SUPPORT										1
9	R01	35J	145	BEARING SUPPORT											1
10	R01	17J	524	DRAIN PLUG										1	1
11	T7W	E20	529	DRAIN PAN ASSY										1
11	T7W	E15	529	DRAIN PAN ASSY											1
12	R01	17J	110	CASING										3
12	R01	35J	110	CASING											3
13	R01	E15	114	SIROCCO FAN										1
13	R01	E20	114	SIROCCO FAN											1
14	R01	E27	202	LIQUID PIPE TEMPERATURE THERMISTOR										1	1							TH2
15	R01	17J	202	COND/EVA TEMPERATURE THERMISTOR										1	1							TH5
16	T7W	H23	480	HEAT EXCHANGER										1	1
	T7W	H24	480	HEAT EXCHANGER											1

31

Image 31

Contents PCA-A30GA ContentsRevised EDITION-B PCA-A24GATechnical Changes Technical Data BookReference Manual Always Observe for Safety Safety PrecautionAdditional refrigerant charge When charging directly from cylinderIndoor Unit Part Names and FunctionsDisplay Section Timer display Operation Mode displayMode Select button Temperature setting displayPCA-A36GA, PCA-A36GA1Single phase, 60Hz, 208/230V SpecificationsService Ref PCA-A30GA, PCA-A30GA1Single phase, 60Hz, 208/230VPCA-A36GA1 Noise Criterion CurvesPCA-A24GA1 PCA-A30GA1PCA-A24GA PCA-A24GA1 PCA-A30GA PCA-A30GA1 Outlines and DimensionsUnit inchmm PCA-A36GA PCA-A42GA PCA-A36GA1 PCA-A42GA1Indoor unit Installation Manual Wiring DiagramHeat exchanger Refrigerant System DiagramTroubleshooting TroubleshootingSELF-DIAGNOSIS Action Table Cause Countermeasure Freezing/overheating protection is Pipe temperatureWorking ErrorE3/signal receiving errorE5 Cause Countermeasure Pipe temperature thermistorRemote controller transmission ErrorE0/signal receiving errorE4Indoor controller board Error Signal receiving errorError Transmitting error Remote controller control boardPly system Troubleshooting by Inferior PhenomenaPhenomena Cause Countermeasure Is offPerformance failure 4Receiver for wireless remoteIs blinking 3Upward/downward vanePage Vane motor MV Between 1 to 3 12.6-13.7V DC Pin1 + Test Point DiagramConnect to the indoor controller board CN2D PCA-A36GA PCA-A36GA1 Models Functions of DIP Switch and Jumper WireRemoving the electrical box Disassembly ProcedureOperating Procedure Photos & Illustrations Removing the air intake grilleRemove the air intake grille Operating ProcedureRemoving the fan motor MF Removing the sirocco fan Removing the Under panel Operating Procedure Photos Removing the vane motor MV Removing the Indoor coil thermistor TH2/TH5Removing the Auto vane Removing the drain panRemoving the guide vane Remove the intake grille. See the figureRemoving the heat exchanger R01 35J 130 Parts No Parts Name SpecificationsDrawing No R01 29J 130Structural Part PCA-A24GA PCA-A30GA PCA-A36GA PCA-A42GA Electrical Parts PCA-A24GA PCA-A30GA PCA-A36GA PCA-A42GA Parts No Parts Name SpecificationsRoHS RemarksStructural Part PCA-A24GA1PCA-A30GA1PCA-A36GA1PCA-A42GA1 Electrical Parts PCA-A24GA1PCA-A30GA1PCA-A36GA1PCA-A42GA1 Wiring RecomRoHS Qty/ set