Mitsubishi Electronics Complete RoHS Parts List for R01-32J-130 in Mitsubishi Air Conditioners

Page 34

13 RoHS PARTS LIST

FAN AND FUNCTIONAL PARTS

PCA-A24GA1PCA-A30GA1

PCA-A36GA1PCA-A42GA1

16

1

15

2

						3

						4

					5
					5																						14



																									13

																							12

																					11
								6

											7
																					10

														8

																	9



	RoHS																		Q'ty/set							Remarks	Wiring		Recom-
No.							Parts Name								Specifications				PCA-A							Remarks	Wiring		Recom-
		Parts No.																	PCA-A								Diagram		mended
		Parts No.																	24/30		36/42 (Drawing No.)						Diagram		mended
																			24/30		36/42 (Drawing No.)						Symbol		Q'ty
																				GA1
1	G	R01	30J	130			MOTOR LEG												1
1	G	R01	32J	130			MOTOR LEG													1
	G	R01	32J	130			MOTOR LEG													1
2	G	R01	45E	126			PIECE(MOTOR)												1	1
3	G	T7W	40J	762			FAN MOTOR							D09C4P70MS					1								MF
3	G	T7W	E31	762			FAN MOTOR							D10C4P90MS						1							MF
	G	T7W	E31	762			FAN MOTOR							D10C4P90MS						1							MF
4	G	R01	800	116			SHAFT JOINT												1	1
5	G	R01	E17	114			SIROCCO FAN												2
5	G	R01	E19	114			SIROCCO FAN													2
	G	R01	E19	114			SIROCCO FAN													2
6	G	R01	H08	202			ROOM TEMPERATURE THERMISTOR												1	1							TH1
7	G	R01	30J	100			SHAFT												1	1
8	G	R01	E02	103			SLEEVE BEARING												1	1
9	G	R01	30J	145			BEARING SUPPORT												1
9	G	R01	36J	145			BEARING SUPPORT													1
	G	R01	36J	145			BEARING SUPPORT													1
10 G		R01	18J	524			DRAIN PLUG												1	1
11	G	T7W	E30	529			DRAIN PAN ASSY												1
11	G	T7W	E31	529			DRAIN PAN ASSY													1
12	G	R01	18J	110			CASING												3
12	G	R01	19J	110			CASING													3
13	G	R01	E15	114			SIROCCO FAN												1
13	G	R01	E20	114			SIROCCO FAN													1
14	G	R01	H10	202			LIQUID PIPE TEMPERATURE THERMISTOR												1	1							TH2
15	G	R01	H09	202			COND/EVA TEMPERATURE THERMISTOR												1	1							TH5
16 G		T7W	H23	480			HEAT EXCHANGER												1	1
	G	T7W	H24	480			HEAT EXCHANGER													1

34

Image 34

Contents PCA-A24GA ContentsRevised EDITION-B PCA-A30GATechnical Changes Technical Data BookReference Manual Safety Precaution Always Observe for SafetyWhen charging directly from cylinder Additional refrigerant chargePart Names and Functions Indoor UnitDisplay Section Temperature setting display Operation Mode displayMode Select button Timer displayPCA-A30GA, PCA-A30GA1Single phase, 60Hz, 208/230V SpecificationsService Ref PCA-A36GA, PCA-A36GA1Single phase, 60Hz, 208/230VPCA-A30GA1 Noise Criterion CurvesPCA-A24GA1 PCA-A36GA1Outlines and Dimensions PCA-A24GA PCA-A24GA1 PCA-A30GA PCA-A30GA1PCA-A36GA PCA-A42GA PCA-A36GA1 PCA-A42GA1 Unit inchmmWiring Diagram Indoor unit Installation ManualRefrigerant System Diagram Heat exchangerTroubleshooting TroubleshootingSELF-DIAGNOSIS Action Table Cause Countermeasure Freezing/overheating protection is Pipe temperatureWorking ErrorE0/signal receiving errorE4 Cause Countermeasure Pipe temperature thermistorRemote controller transmission ErrorE3/signal receiving errorE5Remote controller control board Error Signal receiving errorError Transmitting error Indoor controller boardIs off Troubleshooting by Inferior PhenomenaPhenomena Cause Countermeasure Ply system3Upward/downward vane 4Receiver for wireless remoteIs blinking Performance failurePage Vane motor MV Between 1 to 3 12.6-13.7V DC Pin1 + Test Point DiagramConnect to the indoor controller board CN2D PCA-A36GA PCA-A36GA1 Functions of DIP Switch and Jumper Wire ModelsRemoving the air intake grille Disassembly ProcedureOperating Procedure Photos & Illustrations Removing the electrical boxRemoving the sirocco fan Operating ProcedureRemoving the fan motor MF Remove the air intake grilleRemoving the Indoor coil thermistor TH2/TH5 Operating Procedure PhotosRemoving the vane motor MV Removing the Under panelRemove the intake grille. See the figure Removing the drain panRemoving the guide vane Removing the Auto vaneRemoving the heat exchanger R01 29J 130 Parts No Parts Name Specifications Drawing No R01 35J 130Structural Part PCA-A24GA PCA-A30GA PCA-A36GA PCA-A42GA Electrical Parts PCA-A24GA PCA-A30GA PCA-A36GA PCA-A42GA Remarks Parts Name SpecificationsRoHS Parts NoStructural Part PCA-A24GA1PCA-A30GA1PCA-A36GA1PCA-A42GA1 Electrical Parts PCA-A24GA1PCA-A30GA1PCA-A36GA1PCA-A42GA1 Wiring RecomRoHS Qty/ set