Panasonic NN-S560WF, NN-S560BF, NN-L530BF service manual Confirm after repair, Microwave Radiation

Page 13

6.Confirm after repair

(A)After repair or replacement of parts, make sure that the screws of the oven, etc. are neither loose nor missing.

Microwaves might leak if screws are not properly tightened.

(B)Make sure that all electrical connections are tight before inserting the plug into the wall outlet.

(C)Check for microwave energy leakage. (Refer to procedure for measuring microwave energy leakage.)

CAUTION

MICROWAVE RADIATION

DO NOT BECOME EXPOSED TO RADIATION FROM THE MICROWAVE GENERATOR OR OTHER PARTS CONDUCTING MICROWAVE ENERGY.

IMPORTANT NOTICE	NEW H.V.

1.The following components have potentials above 250V while the appliance is operating..

*Magnetron

*High voltage transformer (Located on Inverter (U))

*High voltage diodes (Located on Inverter (U))

*High voltage capacitors (Located on Inverter (U))

Pay special attention on these portions.

2.When the appliance is operated with the door hinges or magnetron fixed incorrectly, the microwave leakage can reach more than 5mW/cm2. After repair or exchange, it is very important to check if magnetron and the door hinges are correctly fixed.

- 12 -

Image 13

Contents RPH Model refer to the last Microwave OvenContents Inverter Warning Control Panel Feature ChartStop/Reset Pad Operation Scroll Display Operation and Digital Programmer Circuit Test ProcedureChild Schematic Diagram APH Schematic Diagram CPH Inverter Power Supply Circuit NEW H,V Variable power cooking controlVariable Power Cooking Description of Operating SequenceExplanation of the Auto Sensor Cooking process Sensor Cooking NN-S560BFAPH/CPH NNSensor Reheat NN-S560BFAPH/CPH,NN-S560WF APH/CPH Inverter Warnings NEW H.V Check the groundingMicrowave Radiation Confirm after repairDisassembly and Parts Replacement Procedure Until alignment is achieved Door assemblySteam Sensor Inverter Power Supply U Switch and Power Relay B Interlocks Primary Latch Switch, Secondary Secondary LatchShort Switch & Monitor Membrane key board Membrane switch assemblySteam Sensor and Digital Programmer Circuit Measurement of microwave output Measurements and Adjustments1min. test Procedure for measuring radiation leakage Procedure for Measuring Microwave Energy LeakageRecord keeping and notification after measurement Symptom Cause Corrections Troubleshooting GuideDPC Troubleshooting of Inverter Circuit U and Magnetron NEW H.V Trouble Related to Digital Programmer Circuit Exploded View and Parts List Ref.No Part name & Description Pcs Remarks Set Parts ListFAN Motor 4T0 Ref.No Part name & Description Pcs Remarks Set Door AssemblyEscutheon Base Assembly Packing and Accesories Wiring Material Digital Programmer Circuit Parts ListDigital Programmer Circuit Page Page Model for Latin America & Mexico