Bunn CDBCF APS-DV, CDBCF-DV, CDBC APS-DV, CDBC-MV, CDBC-DV, CDBCF APS-MV Limit Thermostat Wiring

Page 26

SERVICE (cont.)

LIMIT THERMOSTAT

P1854

FIG. 6 LIMIT THERMOSTAT

Location:

The limit thermostat is located inside the front access panel on the front side of the tank.

Test Procedures:

1.Disconnect the brewer from the power source.

2.Disconnect the blue and black wires from the limit thermostat.

3.With an ohmmeter, check for continuity across the limit thermostat terminals.

If continuity is present as described, the limit thermo- stat is operating properly.

If continuity is not present as described, replace the limit thermostat.

Removal and Replacement:

1.Remove the black and blue wires from limit ther- mostat terminals.

2.Carefully slide the limit thermostat out from under the retaining clip and remove limit thermostat.

3.Carefully slide the new limit thermostat into the retaining clip.

4.Refer to FIG. 7 when reconnecting the wires.

BLU from Control

Board

BLK from Terminal

Block

P1800

FIG. 7 LIMIT THERMOSTAT WIRING

Page 26	29707 112801

Image 26

Contents DIS Version Introduction APS Brewers TWO Warmer BrewersThree Warmer Brewers No Warmer Brewers CDBCF-DV BrewersCdbc LPTC-DV Brewers ONE Warmer BrewersElectrical HOOK-UP Electrical Requirements1425W Version Models CDBC-MV & CDBC-APS MV Initial SET-UP CleaningPlumbing Requirements Coffee BrewingAdditional Warmer Switches ON/OFF SwitchBrew Switch Ready IndicatorDisplaying Brew Temperature Adjustments & Optional SettingsSetting Brew Temperature Setting Brew LockoutWater Sensing Threshold Adjustment Procedure Troubleshooting Before troubleshooting this brewer, check for the followingRemedy TroubleshootingRefill Circuit Problem Probable Cause Troubleshooting Refill Circuit Heating Circuit Problem Water does not heat to proper tem- peratureTank Heater Troubleshooting Heating CircuitProblem Probable Cause Ings are takenProblem Probable Cause Remedy Brewing Circuit Problem Probable Cause Dispenser Be made with sprayhead installed Troubleshooting Brewing CircuitConsistently low beverage level Brew volume Brew cycle will not start Control board or dispense valveDripping from sprayhead Lime build up Water temperatureSet-upinstructions RequiredProblem Probable Cause Diagnostics Cause Things to CheckComponent Access ServiceWhen servicing, except when electrical tests are re Control Board ServiceDisconnect the 11-pin connector from the control panel Switch Panel Dispense Valve Limit Thermostat Wiring Limit ThermostatTank Heaters Tank Heater Terminal Block Wiring Diagram Voltage Selector Switch Terminals Refill Valve Warmer Elements Warmer ElementsFuse HOLDER/FUSE Assembly MV models only Service Thermal Fuses MV models only Thermal FusesSchematic Wiring Diagram Cdbc DV Schematic Wiring Diagram Cdbc APS-DV Cdbcf APS/TC/LPTC-DV Schematic Wiring Diagram Cdbc MV Schematic Wiring Diagram Cdbc APS MV

Related manuals

Manual 2 pages 47.58 Kb

CDBCF-MV, CDBCF APS-DV, CDBCF APS-MV, CDBC-DV, CDBC-MV specifications

The Bunn CDBCF-DV is a distinguished coffee brewer designed for commercial use, ideal for establishments that demand high-quality coffee at a fast pace. This brewer is notable for its innovative design and advanced brewing technology, making it an essential asset for cafes, restaurants, and coffee shops.

One of the standout features of the Bunn CDBCF-DV is its dual-voltage capability. This versatility allows the brewer to operate efficiently on both 120V and 240V power sources, ensuring that it meets the needs of various establishments regardless of electrical setup. This adaptability makes it a favorite among coffee vendors looking to optimize performance without the inconvenience of electrical constraints.

The BDCBF-DV also boasts a large capacity, allowing it to brew up to 14 cups of coffee in a single cycle. This is facilitated by its large water tank and high brewing rate, which can produce coffee in just a matter of minutes. The ability to brew rapidly while maintaining quality is crucial in busy environments where time is of the essence.

Key to the Bunn CDBCF-DV's performance is its patented brewing system that utilizes a pre-infusion feature. This technology ensures that the coffee grounds are saturated before the brewing process begins, promoting optimal extraction of flavors and aromas. The result is a rich, well-balanced cup of coffee that delights patrons and encourages repeat business.

Another notable characteristic is the brewer's easy-to-use control interface. With simple dial settings, baristas can effortlessly adjust brew strength and temperature, ensuring consistency with every batch. The intuitive design minimizes training time for new staff and enhances overall workflow in commercial settings.

Durability and maintenance are critical in commercial coffee brewing equipment, and the Bunn CDBCF-DV excels in this area as well. Constructed with high-quality materials, it is built to withstand the rigors of daily use. Additionally, it features easily accessible parts for straightforward cleaning and servicing, reducing downtime and ensuring that the coffee remains fresh and delicious.

In summary, the Bunn CDBCF-DV is a versatile, efficient, and user-friendly coffee brewer loaded with innovative features aimed at delivering exceptional coffee quality. Its dual-voltage operation, large capacity, pre-infusion technology, and durable design make it an indispensable choice for businesses looking to enhance their coffee offerings and improve customer satisfaction. Whether you're a small cafe or a larger restaurant chain, the Bunn CDBCF-DV is engineered to meet your coffee brewing demands with excellence.