Bunn CEZF Control Board Cdbc & CEZ, Replace the control board.See, Pages 21, Plumbing lines

Page 15

TROUBLESHOOTING (cont.)

 

 

 

 

 

HEATING CIRCUIT (cont.)

 

 

 

 

 

PROBLEM

 

 

PROBABLE CAUSE

 

 

REMEDY

Spitting or excessive steaming

2a. Temperature Probe (CDBC-APS/

A) Remove the probe from the grom-

(cont.)

TC/TS/TSR)

met and submerge in a water bath

 

 

 

 

 

of approximately 70°F(21°C). Con-

 

 

 

 

 

nect an ohmmeter to pins 3 and 4 of

 

 

 

 

 

the J3 connector. At 60°F(16°C)

 

 

 

 

 

the reading should be 15.3k ± 2k

 

 

 

 

 

OHMS, at 70°F(21°C) the reading

 

 

 

 

 

should be 11.8k ± 2k OHMS, and at

 

 

 

 

 

80°F(27°C) the reading should be

 

 

 

 

 

9.3k ± 2k OHMS. If the probe is

 

 

 

 

 

within these parameters, reconnect

 

 

 

 

 

the J3 plug to the control board.

 

 

2b. Temperature Probe (CEZ-APS/

B) Remove the probe from the grom-

 

 

TS/TSR)

met and submerge in a water bath

 

 

 

 

 

of approximately 70°F(21°C). Con-

 

 

 

 

 

nect an ohmmeter to pins 2 and 3 of

 

 

 

 

 

the J5 connector. At 60°F(16°C)

 

 

 

 

 

the reading should be 15.3k ± 2k

 

 

 

 

 

OHMS, at 70°F(21°C) the reading

 

 

 

 

 

should be 11.8k ± 2k OHMS, and at

 

 

 

 

 

80°F(27°C) the reading should be

 

 

 

 

 

9.3k ± 2k OHMS. If the probe is

 

 

 

 

 

within these parameters, reconnect

 

 

 

 

 

the J5 plug to the control board.

 

 

3. Control Board (CDBC & CEZ)

Set the temperature to 200°F (95°C).

 

 

 

 

 

Let tank temperature stabilize. If

 

 

 

 

 

temperature in tank is above tem-

 

 

 

 

 

perature setting by more than 7°F,

 

 

 

 

 

replace the control board.(See

 

 

 

 

 

pages 21 & 22)

 

 

1. Plumbing lines

Plumbing lines should not rest on

Brewer is making unusual noises

 

 

 

the counter top.

2. Water supply

The brewer must be connected to a

 

 

 

 

 

 

 

cold water supply.

 

 

3. Lime build up

Remove the tank lid and clean in-

 

 

 

 

 

side of tank with a deliming agent, if

 

 

 

 

 

necessary.

Page 15

29253 111103

 

Page 14 Page 16
Image 15
Page 14 Page 16
Contents Phone 217 FAX 217 Post Office BOX SPRINGFIELD, IllinoisIntroduction ContentsUser Notices Electrical Requirements Plumbing RequirementsElectrical Hook-Up Operating Controls ON/OFF SwitchBrew Switch Ready IndicatorCleaning Initial SET-UPCoffee Brewing Adjusting Brew Volumes CEZ-APS/TS/TSR Adjustments & Optional SettingsSetting Brew Lockout CDBC-APS/TC/TS/TSR Adjustments & Optional SettingsSetting Brew Temperature Displaying Brew TemperatureCDBC-APS/TC/TS/TSR Adjustments & Optional Settings Water Sensing Threshold Adjustment ProcedureBefore troubleshooting this brewer, check for the following TroubleshootingRemedy TroubleshootingRefill Circuit Problem Probable Cause2a. Water Level Probe Sensing System CDBC-APS/TS/TSR Troubleshooting Refill CircuitHeating Circuit Problem Probable Cause Remedy Water does not heat to proper temperatureWater not touching temperature probe Problem Probable Cause Remedy Troubleshooting Heating CircuitPages 21 ContControl Board Cdbc & CEZ Replace the control board.SeeBrewing Circuit Problem Probable Cause Troubleshooting Brewing Circuit Required Water temperatureSet-upinstructions Dripping from sprayhead Lime build upProblem Probable Cause Dry coffee grounds remain Sprayhead FunnelFunnel loading Cause Things to Check DiagnosticsService Component AccessContents Control Board ServiceControl Board Service Control Board Model CEZ-APS/TS/TSRSwitch Panel Service Switch Panel Model CDBC-APS/TC/TS/TSRON/OFF Switch Wiring Brew Switch Wiring Service Brew Switch Start Model CEZ-APS/TS/TSRDispense Valve Dispense ValveLimit Thermostat Limit ThermostatTank Heater Tank HeaterTank Heater Wiring Service Tank HeaterCheck for continuity across the refill valve coil terminals Refill ValveLevelsingle Phase 120V AC 2 Wire 120/208V AC 3 Wire 120/240V AC 3 WireSchematic Wiring Diagram CEZ-APS/TS/TSR Cdbc 15, 20 & 35 APS/TC/TS 120V AC 2 Wire

CEZF, CDBC specifications

The Bunn CEZF and CDBC are two popular commercial coffee brewers offered by Bunn, a leader in the coffee equipment industry. Both models are designed to meet the demands of high-traffic settings such as cafes, restaurants, and other foodservice establishments. They combine advanced technology with user-friendly features to ensure consistent, high-quality coffee with minimal effort.

The Bunn CEZF model is known for its easy-to-use design and efficiency. One of its standout features is the "Digital Brewer" control, which allows operators to adjust brewing parameters such as brew time and water temperature. This level of customization enables baristas to consistently create the perfect cup of coffee tailored to their specific blends. Furthermore, the CEZF has a unique "intelligent" warming plate that maintains the optimal serving temperature without over-extraction, ensuring that each cup of coffee remains flavorful.

On the other hand, the Bunn CDBC incorporates a dual brewing capacity that allows for larger batches of coffee to be made simultaneously. This feature is particularly beneficial in high-demand environments where quick service is essential. The CDBC also utilizes a patented brew control technology, enabling users to select their brew strength with just a few button presses. This flexibility is complemented by its high-performance heating element, which heats water rapidly, ensuring that coffee is brewed at the ideal temperature for optimal extraction.

Both models are equipped with a large water reservoir, ensuring a continuous supply of hot water for brewing. They also feature high-quality stainless steel constructions that enhance durability and make cleaning easier. The intuitive interface on both models simplifies operation, with clear instructions that allow even novice users to brew exceptional coffee right away.

In terms of safety, both the CEZF and CDBC are designed with auto shut-off features and integrated safety protocols, minimizing the risk of overheating and ensuring a secure brewing environment.

Overall, the Bunn CEZF and CDBC are excellent choices for any commercial kitchen or café looking to serve high-quality coffee efficiently. Their advanced features, durability, and ease of use make them top contenders in the commercial brewing category.
Top Page Image Contents