Whirlpool W10325493A Pilot and Bypass Screws Conversion, Complete Conversion

Page 13

Pilot and Bypass Screws Conversion

1.Remove control knobs and set aside.

2.Remove upper grates.

3.Lift the cooktop by both front corners until the side support rods snap into position.

4.Open oven door.

5.Locate the two top fasteners and two bottom fasteners and remove them using a Phillips head screwdriver.

A

B

A. Top fasteners

B. Bottom fasteners

6.Set the front panel aside and locate the oven thermostat.

A

A. Oven thermostat

7.Locate the LP gas bypass screw in the bag containing literature included with the range. One LP gas bypass screw is stamped “48.”

8.Remove the Natural gas bypass screw with a flat-blade screwdriver, turning counterclockwise.

9.Install the LP gas bypass screw with a flat-blade screwdriver, turning clockwise.

A

B

A. Pilot screw

B. Bypass screw

10.Locate the LP gas pilot screw in the bag containing literature included with the range. One LP gas pilot screw is stamped “15.”

11.Remove Natural gas pilot screw with a flat-blade screwdriver, turner counterclockwise.

12.Install the LP gas pilot screw with a flat-blade screwdriver, turning clockwise.

13.Replace the front panel and screw bottom and top fasteners in place.

14.Replace the control knobs. Push back on the side support rods and slowly lower the cooktop until it snaps into position. Close the oven door.

Complete Conversion

1.Refer to the “Make Gas Connection” section for properly connecting the range to the gas supply.

2.Turn the manual shutoff valve in the gas supply line to the open position.

3.Refer to the “Check Operation” section for proper burner ignition, operation and burner flame adjustments.

IMPORTANT: You may have to adjust the “LO” setting for each cooktop burner.

Checking for proper cooktop and oven burner flames is very important. The small inner cone should have a very distinct blue flame ¼" to ½" (0.64 cm to 1.3 cm) long. The outer cone is not as distinct as the inner cone. LP gas flames have a slightly yellow tip.

4.Close the broiler door and turn the knob to “OFF.”

5.Refer to the “Complete Installation” section to complete this procedure.

Natural Gas Conversion

To Convert Gas Pressure Regulator

WARNING

Tip Over Hazard

A child or adult can tip the range and be killed.

Connect anti-tip bracket to rear range foot.

Reconnect the anti-tip bracket, if the range is moved.

Failure to follow these instructions can result in death or serious burns to children and adults.

1.Turn manual shutoff valve to the “closed” position.

B

A

C

A. To range

B. Manual shutoff valve “closed” position

C. Gas supply line

2.Remove grates.

3.Lift the cooktop by both front corners until the side support rods snap into position.

13

Page 12 Page 14
Image 13
Page 12 Page 14
Contents Table of Contents/Table des matières Your safety and the safety of others are very important Range SafetyTools and Parts Installation RequirementsLocation Requirements Product Dimensions Freestanding Range Mobile Home Additional Installation RequirementsInstallation Clearances Mobile home installations requireGas Supply Requirements Install Anti-Tip Bracket Installation InstructionsLine pressure testing above ½ psi gauge 14 WCP Line pressure testing at ½ psi gauge 14 WCP or lowerMake Gas Connection Level Range Verify Anti-Tip Bracket LocationTypical rigid pipe connection Typical flexible connectionCheck Operation If the low flame needs adjustingCheck Operation of Oven/Broil Burner To Light Standing Pilot LightsIf the flame needs adjusting Complete InstallationIf you need Assistance or Service Too much air of flame should occurLP Gas Conversion GAS ConversionsTo Convert Gas Pressure Regulator Turn manual shutoff valve to the closed positionTo Convert Oven Burner To Convert Surface BurnersComplete Conversion Pilot and Bypass Screws ConversionNatural Gas Conversion Set the front panel aside and locate the oven thermostatInstall Natural gas orifice spuds in the valves Pilot and Bypass Screws Conversion Votre sécurité et celle des autres est très importante Sécurité DE LA CuisinièreExigences d’emplacement Exigences D’INSTALLATIONOutillage et composants Distances de dégagement à respecter Dimensions du produit Cuisinière autoportanteType de gaz Spécifications de l’alimentation en gazGaz naturel Conversion pour lalimentation au propaneDétendeur Canalisation dalimentation en gazDébit thermique des brûleurs Tests de pressurisation de la canalisation de gazInstallation de la bride antibasculement Instructions D’INSTALLATIONDéballage de la cuisinière Fixer le gabarit avec du ruban adhésifRaccordement au gaz Raccordement typique à une canalisation rigide Vérification de lemplacement de la bride AntibasculementRaccordement typique par raccord flexible Achever le raccordementContrôle du fonctionnement Réglage de laplomb de la cuisinièrePour allumer les témoins de veilleuse Contrôle du fonctionnement du four Brûleur du gril Remettre en place le bouton de commandeSi la flamme basse doit être réglée Ouvrir la porte du grilSi vous avez besoin d’assistance ou de service Achever l’installationSi la flamme doit être réglée Si la cuisinière ne fonctionne pas, contrôler ce qui suitConversion pour lalimentation au propane Conversions Pour Changement DE GAZConversion du détendeur Placer le robinet d’arrêt manuel à la position ferméeConversion du brûleur du four Conversion des brûleurs de surfaceImportant Ne pas serrer excessivement Terminer la conversion Conversion des veilleuses et des vis de DérivationConversion au gaz naturel Conversion du brûleur du four Terminer la conversion

W10325493A specifications

The Whirlpool W10325493A is a high-performance appliance that brings efficiency and convenience to modern kitchens. As a part of Whirlpool's commitment to innovative technology, this model embodies a range of features designed to enhance cooking experiences.

One of the standout features of the W10325493A is its advanced cooking technology. It includes a powerful convection system that ensures even heat distribution around meals, promoting uniform cooking and browning. This is particularly beneficial when roasting or baking large items, as it reduces cooking time and ensures that every inch of food is perfectly treated.

In addition to its convection feature, the W10325493A also boasts a user-friendly touch control panel. This panel allows users to easily select desired cooking modes, temperatures, and times with just a few taps. The intuitive interface makes it accessible for all skill levels, from novice cooks to seasoned chefs. Furthermore, its digital display provides clear visibility of cooking settings, helping users keep track of their culinary tasks.

Another remarkable characteristic of the W10325493A is its spacious interior. With ample cooking space, this appliance accommodates large dishes without compromise. Whether preparing a family feast or entertaining guests, the generous capacity makes it easier to manage multiple items simultaneously. This versatility is complemented by adjustable racks that provide flexibility in organizing cooking trays and pans.

Energy efficiency is another critical feature of the W10325493A. With its eco-friendly design and energy-saving modes, this appliance minimizes energy consumption without sacrificing performance. This not only reduces utility bills but also reflects a commitment to environmental sustainability.

The W10325493A also integrates smart technology capabilities. With Wi-Fi connectivity, users can monitor and control the appliance remotely via a smartphone app. This feature allows for setting timers, adjusting temperature settings, and even receiving notifications when dishes are ready, making it a convenient addition to any busy household.

Lastly, the sleek and modern exterior of the W10325493A complements any kitchen aesthetic. Its stainless-steel finish is not only visually appealing but also easy to maintain, ensuring it looks great for years to come.

In summary, the Whirlpool W10325493A is a multifaceted appliance that combines advanced cooking technology, user-friendly features, energy efficiency, and smart connectivity, making it an excellent choice for enhancing culinary experiences in any home.
Top Page Image Contents