Cornelius service manual UC 701 Series CONTINUOUS-FLOW Icemaker

Page 1

IMI CORNELIUS INC g One Cornelius Place g Anoka, MN 55303-6234

Telephone (800) 238-3600

Facsimile (800) 535-4231

Installation/Service Manual

UC 701 SERIES CONTINUOUS–FLOW ICEMAKER

IMPORTANT:

TO THE INSTALLER.

It is the responsibility of the Installer to ensure that the water supply to the dispensing equipment is provided with protection against backflow by an air gap as defined in ANSI/ASME A112.1.2-1979; or an approved vacuum breaker or other such method as proved effective by test.

Water pipe connections and fixtures directly connected to a potable water supply shall be sized, installed, and maintained according to Federal, State, and Local Codes.

Part No. 630460150

February 2001

Revision Date: November 7, 2003

Revision A

THIS DOCUMENT CONTAINS IMPORTANT INFORMATION

This Manual must be read and understood before installing or operating this equipment

 IMI CORNELIUS INC; 2000–2003	PRINTED IN U.S.A

Image 1

Contents UC 701 Series CONTINUOUS-FLOW Icemaker Table of Contents Table of Contents cont’d Recognize Safety Information Safety InformationUnderstand Signal Words Follow Safety InstructionsThis page Left Blank Intentionally To the User of this Manual General DescriptionDescription Claims InstructionsSpecification Chart Clearance Requirements This page Left Blank Intentionally PRE-INSTALLATION InstallationSide Bracket Installation InstallationIcemaker Float Assembly Initial Start UP, Checks and Adjustment InstructionsThis page Left Blank Intentionally Icemaker Cleaning and Sanitizing Procedures Guide to ServiceMaintenance MonthlySemi-Annually Water Level ControlHow Water Level Control Works PurposeTo Replace Water Level Safety Switch Refrigeration System AdjustmentsRefrigeration System To Replace Water Level ControlExpansion Valve Adjustment and TroubleshootingCondenser Modulating Valve BIN Control Condenser Modulating Valve RemovalMotor Check GearmotorStart Relay To Replace Gearmotor AssemblyAuger and Extruding Head Removal Upper NUT and Bearing AssemblyTo Replace Bearing Capacitor Check Electrical CheckoutGear Motor Overload Safety ControlsGuide to Good ICE Wiring Diagram Troubleshooting Chart Icemaker not Operating Troubleshooting Compressors TroubleshootingIMI Cornelius Certificate of WarrantyThis page Left Blank Intentionally IMI Cornelius INC