AEG C41022GN manual Gas regulations, Connecting to LPG, Minimum flow of valved cooking hob taps

Instructions for the installer

12.7 Gas regulations

If the cooking appliance is set up for a different type of gas than that available, its injectors must be replaced, the minimum flow regulated. In order to replace the injectors in the cooking hob, it is necessary to carry out the following operations:

•remove the pan supports;

•remove the burners and burner caps (Fig. A);

•take out the injector (Fig. B) and replace it with one

suitable for the new type of gas (see "GENERAL INJECTORS TABLE");

•replace the gas label (on the rear of the appliance) with the new one provided with the injectors kit;

•refit all parts by following the disassembly instructions in reverse order and taking care to position the burner cap correctly on the burner.

12.7.1Minimum flow of valved cooking hob taps

•Switch on the burner and turn the control knob towards the minimum flow position ;

•remove the knob;

•using a screwdriver, adjust the internal screw Z until the correct low flame is obtained;

•refit the knob.

12.7.2Minimum flow of non-valved cooking hob taps

•Switch on the burner and turn the control knob towards the minimum flow position ;

•remove the knob;

•insert a small screwdriver into the rod of the tap and adjust the internal screw Z until the correct low flame is obtained;

•refit the knob.

•Unscrew the adjustment screw Z to increase the flow, or tighten it to reduce the flow.

•The adjustment is correct when the low flame measures approximately 3 or 4 mm.

•When changing quickly from maximum to minimum flow and vice versa make sure that the flame does not go out.

GENERAL INJECTORS TABLE

TYPE OF GAS	mBar	NOZZLE NO.	BURNERS
			POSITION TYPE
		115	RAPID
		97	SEMI RAPID
NATURAL GAS	20	72	AUXILIARY
		128	TRIPLE-RING
		94	FISH KETTLE
		85	RAPID
LPG	30	65	SEMI RAPID
BUTANE	28	50	AUXILIARY
PROPANE	37
		93	TRIPLE-RING
		68	FISH KETTLE

POWER Watt		CONSUMPTION
MAX.	MIN.	MAX.
3000	750	286 l/h
1750	480	167 l/h
1000	330	95 l/h

3300	1300	314 l/h
1900	750	181 l/h
3000	750	219 g/h
1750	480	128 g/h
1000	330	73 g/h
3300	1300	241 g/h
1900	750	138 g/h

12.8 Connecting to LPG

Use a pressure regulator and connect to the cylinder in compliance with the guidelines set out in standards regulations in force.

Note: L.P.G. cookers MUST NOT be installed below ground level i.e. in a basement or aboard any boat, yacht or other vessel.