Multi Tech Equipment MVH306DS2, MVH306DSCPAS Battery Maintenance Option, Adding Hydraulic Oil

Page 27

2.Using a funnel, add Shell Tellus Oil #32 or equivalent to the hydraulic oil tank through the oil filler port (Figure 36). Oil tank capacity is 18.7 fl. oz (550 cc).

HYDRAULIC

OIL TANK

S

 

 

 

FILL TO

TE EL

H

 

 

 

 

L

L

 

0I

 

L

 

 

 

U

THIS LEVEL

L

#46

 

S

 

OIL LEVEL

FRONT VIEW

REAR VIEW

Figure 36. Adding Hydraulic Oil

CAUTION

Make sure hydraulic oil is at a normal safe operating level. DO NOT over fill. Over filling (excessive oil) will cause excess oil to blow out of breather plug.

3.Loosen bleeder plug located at top of hydraulic cylinder on side of vibrator (Figure 37). Air remaining in the circuit will be forced out of the bleeder plug. Once all air has been purged from the hydraulic system, tighten bleeder plug securely

4.Reinsert oil plug into hydraulic oil tank and tighten securely. Reinstall breather cap.

NOTICE

The bleeder plug should only be loosened, but not removed.

BLEEDER

PLUG

HYDRAULIC

CYLINDER

Figure 37. Bleeder Plug

maintenance

CAUTION

ALWAYS wear safety glasses or face mask, protective clothes, and rubber gloves when working with battery.

BATTERY MAINTENANCE (Option)

Mishandling of the battery shortens the service life of the battery and adds to maintenance cost. When handling the battery do the following:

„„The battery electrolyte contains sulfuric acid, be careful not to let the battery electrolyte come in contact with your body or clothing.

„„Always check the battery terminals periodically to ensure that they are in good condition.

„„Always wear eye protection and rubber gloves, since the battery contains sulfuric acid which burns skin and eats through clothing. In case of contact, flush thoroughly with water and contact a doctor immediately.

„„Use wire brush or sand paper to clean the battery terminals.

„„Always check battery for cracks or any other damage. If white pattern appears inside the battery or paste has accumulated at the bottom, replace the battery.

„„If the compactor will not be in operation for a long period of time, store in cool dry place and check the battery charge level every month to maintain the performance of the battery.

„„Check the battery regularly and make sure that each electrolyte level is to the bottom of the vent well (Figure 38). If necessary add only distilled water in a well-ventilated area.

Figure 38. Battery Electrolyte Levels

mvh306ds2/dsCPAs pLATE COMPACTOR • operation and parts manual — rev. #7 (02/04/14) — page 27

Page 26 Page 28
Image 27
Page 26 Page 28
Contents Series Model MVH306DS2/ MVH306DSCPAS Diesel engine exhaust and some PROPOSITION 65 WarningPage Table of Contents Choose from three easy options Safety Messages Safety InformationGeneRaL saFeTY Before servicing equipment Engine saFeTYFueL saFeTY BaTTeRY saFeTY eLeCTRiC sTaRT OnLY„ Use well-insulated gloves when picking up the battery Emission Control Label TRanspORTing saFeTYEnviROnmenTaL saFeTY/deCOmmissiOning EmissiOns inFORmaTiOnYanmar SpecificationsDimensions DimensionsGeneral nformation MVH306DS2/DSCPAS Reversible Plate Compactor Components ComponentsFuel Tank Capacity is 3.5 quarts 3.31 liters of diesel fuel Basic engineChecking the Hydraulic Oil Level Using a 24 mm wrench, remove the hydraulic oil filler plugBefore Starting Checking Engine Oil LevelRemove the fuel cap located on top of fuel tank Checking the Air CleanerLoosen the wing nut , remove the air cleaner cover Checking The FuelAdjusting Handle Height OperationReleasing the Handle If the engine does not start, repeat steps 1 thru Recoil StartMove the throttle lever to the Start position Figure Push down decompression lever and releaseNormal Shutdown TravelingPush up the handle upward until the handle locks in place Emergency ShutdownCompaction Sensor MVH306 Dscpas Only Normal Compaction Compaction LimitFunction to Detect Electric System Abnormality System Diagnostics to Detect Operational Abnormalities„„Check for leakage of fuel or oil MaintenanceInspection and Maintenance Service Tables Daily ServiceReplacing the V-belt Engine Oil ReplacementReinstalling the V-belt Air Filter Every 6 Months or 400 HoursAdding Hydraulic Oil Vibrator Oil Level CheckDraining Vibrator Oil Draining Hydraulic OilAdding Hydraulic Oil Battery Maintenance OptionReinstall fuel filter and connect all associated hardware Battery Cable Connection OptionLong Term Storage Explanation of Code in Remarks Column Suggested Spare Parts Nameplates and decals Decal Shell Tellus OIL Decal OIL SAE 10W-30Decal Model Logo MVH-306 Decal CautionVibrating Plate Assy Packing 1/4 CU Vibrating PlateDrain Plug Copper PackingBase and Engine Assy DUST-PROOF Sponge BaseEngine ASSY. L70V6 Yanmar Belt CoverBase and Engine Assy WASHER, Lock M14 Drain JointClamp TC-100 Guard HookVibrator Assy Rotary SHAFT, Drive Includes Items W/ #Vibrating Case Roller Bearing NJ310EMC4Control Handle Assy Rubber Coupling Handle BracketHandle Bracket R WASHER, Flat M12Control Handle Assy Handle W/GRIP Rubber COLUMN, HandleTravel Lever Handle BossHand Pump Assy Bush AccumlatorIncludes Items W/# Control ShaftBattery Assy Battery 55B24L Battery Cord 400LBattery Cord + 550L CRADLE, BatteryCOMPACTION Analyzing System ASSY. mVH3O6DSCPAS Compaction Sensor Panel Wire HARNESS, SensorWire Harness Wire CLIP,SENSORElectric Device Assy Ignition KEY Wire CPHarness C, Wire Buzzer EBLYanmar L70V6 Cylinder Block Assy Shim SET Cylinder Block AssyCylinder Head Gasket Assy RingYanmar L70V6 Cylinder head Assy Valve Spring Adjusting ScrewIntake Valve Exhaust ValveYanmar L70V6 air cleaner Assy Wing NUT AIR Cleaner BodyAIR Cleaner Cover AIR Cleaner GasketYanmar L70V6 Muffler Assy Stud M8X18 Plated Muffler GasketMuffler Assy Bolt M6X14 PlatedYanmar L70V6 Crankshaft and Camshaft Assy Push ROD Assy Camshaft AssyTappet Roller Tappet AssyYanmar L70V6 Piston Assy Circlip Piston Rings SET = STDPiston Ring SET OS = Piston PINYanmar L70V6 LUB OIL Pump and Governor Assy Ring Cover Adjusting BoltLUB. OIL Pump Assy LUB. OIL Pump CoverYanmar L70V6 Cooling and Starting Device Assy TOP COVER, Black Tank GrommetSide Cover B Side Cover aYanmar L70V6 Fuel Injection Pump Assy Nozzle Spring Nozzle AssyNozzle NUT PINYanmar L70V6 Fuel Tank and Fuel Line Assy Pipe Guage PackingCAP Valve FILTER, FuelYanmar L70V6 Starting Motor and Dynamo Assy Thrust Washer KIT Gear Housing AssyMagnet Switch ArmatureYanmar L70V6 TOOL, LABEL, and Gasket Assy Diesel Label HOW to START- E LabelAIR Cooled Label Yanmar LabelFReighT pOLiCY Terms and Conditions of Sale PartsPage HERE’S HOW to GET Help
Top Page Image Contents