TROUBLESHOOTING | CHART |
|
|
|
| ||||||||
PROBLEM |
| CAUSE |
|
|
|
|
|
|
| ||||
Loss |
| of power | • | Cutting |
| too | much grass/too | ||||||
|
|
|
|
| fast. |
|
|
|
|
|
|
|
|
|
|
|
| • | Throttle |
| in"CHOKE" | ||||||
|
|
|
|
| position. |
|
|
|
|
|
| ||
|
|
|
| • |
| of grass, | leaves | ||||||
|
|
|
|
| and trash | under | mower. | ||||||
|
|
|
| • | Dirty | air | filter. |
|
|
| |||
|
|
|
| • | Low | oil | level/dirty |
| oil. | ||||
|
|
|
| • | Faulty | spark plug. |
| ||||||
|
|
|
| • | Dirty | fuel | filter. |
|
|
| |||
|
|
|
| • | Stale | or | dirty fuel. |
| |||||
|
|
|
| • | Water | in fuel. |
|
|
| ||||
|
|
|
|
| Spark | plug | wire | loose. | |||||
|
|
|
| • | Dirty | engine | air screen/fins. | ||||||
|
|
|
| • | Dirty/clogged | muffler. | |||||||
|
|
|
| • | Loose | or damaged | wiring. | ||||||
|
|
|
| • | Carburetor | out | of |
| |||||
|
|
|
|
| adjustment. |
|
|
|
| ||||
|
|
|
| • | Engine |
| valves | out | of | ||||
|
|
|
|
| adjustment. |
|
|
|
| ||||
Excessive |
| • | Worn, | bent | or loose blade. | ||||||||
vibration |
|
|
|
|
|
|
|
|
|
|
| ||
|
|
|
|
| Bent | blade | mandrel. | ||||||
|
|
|
|
| Loose/damaged |
| part(s). | ||||||
I |
| continues | • |
|
|
|
|
|
|
|
|
| |
IEngme | Faulty | ||||||||||||
!to run when | oper- |
| presence | control | system. | ||||||||
lator | leaves | seat |
|
|
|
|
|
|
|
|
|
| |
with | attachment |
|
|
|
|
|
|
|
|
|
| ||
clutch | engaged |
|
|
|
|
|
|
|
|
|
|
Poor cut- uneven • Worn, bent or loose blade.
Mower deck not level.
Buildup of grass, leaves, and trash under mower. Bent blade mandrel.
Clogged mower deck vent holes from buildup of grass, leaves, and trash around mandrels.
Mower blades will • | Obstruction | in | clutch | |
not rotate | mechanism. |
|
| |
| Worn/damaged | mower | ||
| drive belt. |
|
| |
| Frozen | idler | pulley. | |
| Frozen | blade | mandrel. |
CORRECTION
•Set in "Higher Cut" position/ reduce speed.
•Adjust throttle control.
•Clean underside of mower housing.
•Clean/replace air filter.
•Check oil level/change oil.
•Clean and regap or change spark plug.
•Replace fuel filter.
•Drain fuel tank and refill with fresh gasoline.
•Drain fuel tank and carburetor refill tank with fresh gasoline and replace fuel filter.
•Connect and tighten spark plug wire.
•Clean engine air screen/fins.
•Clean/replace muffler.
•Check all wiring.
•See "To Adjust Carburetor" in Service Adjustments section.
•Contact an authorized service center/department.
•Replace blade. Tighten blade bolt.
•Replace blade mandrel.
•Tighten loose part(s). Replace damaged parts.
Check wiring, switches and connections. If not
corrected, contact an autho rized service center/
department.
•Replace blade. Tighten blade bolt.
•Level mower deck.
•Clean underside of mower housing.
•Replace blade mandrel.
•Clean around mandrels to open vent holes.
•Remove obstruction.
•Replace mower drive belt.
•Replace idler pulley.
•Replace blade mandrel.
29