Sears 917.25271 owner manual Troubleshooting Points, Problem Cause Correction

Page 28

i

i

i

iii

TROUBLESHOOTING POINTS

PROBLEM

CAUSE

CORRECTION

I IIII

 

 

Will not start

1. Out of fuel.

2.Engine not =CHOKED" properly.

3.Engine flooded.

4, Bad spark plug.

5.Dirty air filter.

6.Dirty fuel filter,

7.Water in fuel.

8.Loose or damaged wiring.

9.Carburetor out of adjustment.

10.Engine valves out of adjustment.

Hard

to start

1.

Dirty

air filter.

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

2.

Bad spark

plug,

 

 

 

 

 

 

3.

Weak

or dead

battery.

 

 

 

 

4.

Dirty

fuel

filter.

 

 

 

 

 

 

5.

Stale

or dirty

fuel.

 

 

 

 

 

6.

Loose

or damaged

wiring,

 

 

 

7.

Carburetor

out of adjustment.

 

 

 

8.

Engine valves out of adjustment.

Engine

will not turn over

1.

Clutch/brake

pedal

not depressed.

 

 

 

2.

Attachment clutch

is engaged.

 

 

 

3.

Weak

or dead

 

battery.

 

 

 

 

4.

Blown

fuse.

 

 

 

 

 

 

 

 

5.

Corroded

battery

terminals.

 

 

 

6.

Loose

or damaged

wiring.

 

 

 

 

7.

Faulty

ignition

 

switch.

 

 

 

 

8.

Faulty

solenoid

or starter.

 

 

 

 

9.

Faulty

operator

presence

switch(es).

Engine

clicks but will not

1.

Weak

or dead

 

battery.

 

start

 

 

2.

Corroded

battery

terminals.

 

 

 

 

 

 

3. Loose or damaged wiring.

 

 

 

 

4. Faulty solenoid or starter.

 

Loss

of power

1.

Cutting too much

grass/too

fast.

 

 

 

2. Throttle in "CHOKE" position.

 

 

 

3. Build-up of grass, leaves and trash under mower.

 

 

 

4.

Dirty

air filter.

 

 

 

 

 

 

 

 

5,

Low

oil level/dirty

oil.

 

6.Faulty spark plug.

7.Dirty fuel filter.

8.Stale or dirty fuel.

9.Water in fuel.

10.Spark plug wire loose.

11.Dirty engine air screen/fins.

12.Dirty/clogged muffler.

13.Loose or damaged wiring.

14.Carburetor out of adjustment.

15.Engine valves out of adjustment.

Excessive vibration

1.

Worn,

bent

or loose blade.

 

2.

Bent

blade

mandrel.

 

3.

Loose/damaged part(s).

1.Fill fuel tank.

2.See "TO START ENGINE" in Operation section.

3.Wait several minutes before attempting to start.

4.Replace spark plug.

5.Clean/replace air filter.

6.Replace fuel filter.

7.Drain fuel tank and carburetor, refill tank with fresh gasoline and replace fuel filter.

8.Check all wiring.

9.Contact an authorized service center/department.

10.Contact an authorized service center/department.

1.Clean/replace air filter.

2.Replace spark plug.

3.Recharge or replace battery.

4.Replace fuel filter.

5.Drain fuel tank and refill with fresh gasoline,

6.Check all wiring.

7.Contact an authorized service center/department.

8.Contact an authorized service center/department.

1.Depress clutch/brake pedal. 2, Disengage attachment clutch. 3, Recharge or replace battery.

4.Replace fuse,

5.Clean battery terminals.

6.Check all wiring.

7.Check/replace ignition switch.

8.Check/replace solenoid or starter.

9.Contact an authorized service center/department.

1.Recharge or replace battery.

2.Clean battery terminals.

3.Check all wiring.

4.Check/replace solenoid or starter.

1.Set in "Higher Cur' position/reduce speed.

2.Adjust throttle control.

3.Clean underside of mower housing.

4.Clean/replace air filter.

5.Check oil level/change oil.

6.Clean and regap or change spark plug.

7.Replace fuel tilter.

8.Drain fuel tank and refill with fresh gasoline.

9.Drain fuel tank and carburetor, refill tank with fresh gasoline and replace fuel filter.

10.Connect and tighten spark plug wire.

11.Clean engine air screen/fins.

12.Clean/replace muffler.

13.Checkall wiring.

14.Contact an authorized service center/department.

15.Contact an authorized service center/department.

1.Replace blade. Tighten blade bolt.

2.Replace blade mandrel.

3.Tighten loose part(s), Replace damaged parts.

28

Page 27 Page 29
Image 28
Page 27 Page 29
Contents Page Safety Rules Safe Operation Practices for Ride-On MowersProduct Specifications Maintenance AgreementLimited 90 DAY Warranty on Battery Contents Engine Maintenance PerformanceContents Tools Required for Assembly To Remove Tractor from CartonBefore Rolling Tractor OFF Skid Unpack CartonAssembly HOW to SET UP Your TractorPrepare Battery See Figs a and 2B Install Seat See FigCheck Tire Pressure Check Deck LevelnessCheck for Proper Position of ALL Belts Check Brake SystemChecklist Install Mulcher PlateSee Figs a & 7B To Convert to Bagging or DischargingOperation Know Your TractorHOW to USE Your Tractor To Move Forward and BackwardBefore Starting the Engine To Operate Mower See FigTo Operate on Hills Check Engine OIL Level See FigTo Start Engine See Fig ADD GasolinePurge Transmission Mowing Tips Mulching Mowing TipsLubrication Chart General RecommendationsLub.caoncha Before Each USECustomer Responsibilities TractorBrake Operation TiresEngine Transaxle CoolingTransaxle Pump Fluid AIR Filter See FigCleaning Engine OIL FilterMuffler Spark PlugsTo Install Mower See Fig Service and AdjustmentsTo Remove Mower See Fig Adjustments To Level Mower HousingTo Adjust Brake See Fig ServiceTo Replace Mower Blade Drive Belt See Fig Adjustm NTS To Adjust Motion Control Lever See FigTransmission REMOVAL/REPLACEMENT To Replace Motion Drive Belt See FigTo Adjust Steering Wheel Alignment To Start Engine with a Weak BatteryFront Wheel TOE-IN/CAMBER See FigTo Remove Hood and Grill Assembly To Replace Headlight BulbInterlocks and Relays To Replace FuseTo Adjust Carburetor See Fig To Adjust Throttle Control CableSee Storage OtherTroubleshooting Points Problem Cause CorrectionProblem Cause Service Notes JlJ Tractor - Model NumberTractor --MODEL Number ElectricalTractor -- Model Number KEY Part NO. NO.DESCRIPTIONChassis and Enclosures KEY Part Description Drive Repair Parts Steering Assembly Steering Wheel Axle Assembly, Front Spindle Assembly, LH Engine 4218122439X Seat Assembly UNCDecals Wheels & TiresMower Lift 161718BIkZinc 73800800 Nut LockW/Wsh 13 Unc 139868 Arm Suspension Mower Deck Inch = Tractor - Model Number Hydro Gear Transaxle Model Number 142930 D,,RUD,,I Kohler ENGINE- Model Number MV18.OS, Type Number PS58560Kohler Engine Model Number MV18.OS, Type Number PS58560 AIR Intake KEY Part DescriptionCarbu Retor J Crankcase Dipstick Screw 1/4-20 x 5/8 Service Notes Service Notes Service Notes Suggested Guide for Sighting Slopes for Safe Operation If YOU Need Repair Service or Parts Model noPage Safety Rules Maintenance Agreement Contents Accessories Attachments Contents Assem BLY Assembly Check Tire Pressure Checklist Operation HOW to USE Your Tractor Before Starting the Engine Fii AcAuieverenIioiiii Operation SE.V.C Customer Responsibilities Engine Cleaning Service and Adjustments Adjustments Service Adjustm NTS Service and Adjustments Adjustments Sc. w Storage Troubleshooting Points Problem Cause Service Notes JlJ Repair Parts Tractor -- Model Number Tractor - Model Number KEY Part Description Drive Repair Parts Steering Assembly Tractor -- Model Number Spark Arrester 122439X Tractor -- Model Number Tractor --MODEL Number Tractor - Model Number BIkZinc 73800800 Nut LockW/Wsh 13 Unc 139868 Arm Suspension Tractor --MODEL Number Tractor - Model Number Tractor - Model Number Hydro Gear Transaxle Model Number 142930 D,,RUD,,I Tractor --MODEL Number Tractor --MODEL Number Tractor - Model Number Tractor -- Model Number Screw 1/4-20 x 5/8 Service Notes Service Notes Service Notes Suggested Guide for Sighting Slopes for Safe Operation HP Twin Cylinder Electric Start

917.25271 specifications

The Sears 917.25271 is a robust and versatile garden tractor that has earned its place in the hearts of gardening enthusiasts and lawn care professionals alike. With its impressive blend of features, technologies, and characteristics, this tractor is designed to meet various landscaping and maintenance needs while ensuring user satisfaction and operational efficiency.

One of the standout features of the Sears 917.25271 is its powerful engine. Equipped with a strong and reliable gas-powered engine, the tractor delivers ample horsepower to tackle even the toughest mowing jobs. This ensures that users can efficiently manage their lawns, regardless of terrain type or grass thickness. The smooth operation of the engine is complemented by an easy-to-use ignition system, allowing users to start the tractor with minimal effort.

The design of the 917.25271 prioritizes comfort and usability. Its ergonomic seat provides ample cushioning, reducing fatigue during longer mowing sessions. The adjustable seat allows users of different heights to find their optimal driving position, enhancing overall comfort and control. Moreover, the tractor features a user-friendly control panel, enabling easy access to all essential functions such as speed adjustments, blade engagement, and throttle control.

Another notable technology incorporated into the Sears 917.25271 is its advanced cutting system. The tractor includes a durable mower deck that ensures a clean and even cut, contributing to a well-maintained lawn appearance. The ability to easily adjust the cutting height makes it adaptable to different grass types and seasonal variations, ensuring efficient lawn care throughout the year.

Durability is a key characteristic of the 917.25271. Constructed with high-quality materials, it is designed to withstand the rigors of outdoor use. The reinforced chassis and strong tires provide excellent traction and stability on varied terrain, making it suitable for larger lawns and uneven landscapes.

Additionally, the Sears 917.25271 offers versatility through its attachment options. Users can enhance the tractor's capabilities with various accessories such as snow plows, baggers, and tillers. This adaptability allows it to serve multiple functions, making it a valuable tool not just for mowing, but for year-round landscaping projects.

In conclusion, the Sears 917.25271 stands out for its powerful engine, user-friendly design, advanced cutting technology, and unmatched durability. These attributes make it an essential choice for anyone looking to simplify their lawn care routines and achieve professional results.
Top Page Image Contents