Multiquip GDP-5H Rules for Safe Operation, Read this manual

Page 8

GDP-5H — RULES FOR SAFE OPERATION

 

DANGER

Read this manual!

 

 

 

Failure to follow instructions in this manual may lead to serious injury or even death! This equipment is to be operated by trained and qualified personnel only! This equipment is for industrial use only.

The following safety guidelines should always be used when operating the GDP-5H Portable Generator:

GENERAL SAFETY

DO NOT operate or service this equipment before reading this entire manual.

This equipment should not be operated by persons under 18 years of age.

NEVER operate this equipment without proper protective clothing, shatterproof glasses, steel-toed boots and other protective devices required by the job.

NEVER operate this equipment when not

feeling well due to fatigue, illness or taking medicine.

NEVER operate this equipment under the influence of drugs or alcohol.

ALWAYS wear proper respiratory (mask), hearing and eye protection equipment when operating the generator.

Whenever necessary, replace nameplate, operation and safety decals when they become difficult read.

Manufacturer does not assume responsibility for any accident due to equipment modifications.

NEVER use accessories or attachments, which are not recommended by Multiquip for this equipment. Damage to the equipment and/or injury to user may result.

NEVER touch the hot exhaust manifold, muffler or cylinder. Allow these parts to cool before servicing engine or generator.

The engine section of this generator requires an adequate free flow of cooling air. NEVER operate the generator in any enclosed or narrow area where free flow of the air is restricted. If the air flow is

restricted it will cause serious damage to the generator or engine and may cause injury to people. Remember the generator's engine gives off DEADLY carbon monoxide gas.

ALWAYS refuel in a well-ventilated area, away from sparks and open flames.

ALWAYS use extreme caution when working with flammable liquids. When refueling, stop the engine and allow it to cool.DO NOT smoke around or near the machine. Fire or explosion could result from fuel vapors, or if fuel is spilled on a hot engine.

NEVER operate the generator in an explosive atmosphere or near combustible materials. An explosion or fire could result causing severe bodily harm or even death.

NEVER disconnect any "emergency or safety devices". These devices are intended for operator safety. Disconnection of these devices can cause severe injury, bodily harm or even death! Disconnection of any of these devices will void all warranties.

PAGE 8 — GDP-5H A.C. GENERATOR— PARTS & OPERATION MANUAL — REV. #2 (10/05/05)

Image 8 Contents
Model GDP-5H Page Heres HOW to GET Help Table of Contents Parts Ordering Procedures When ordering parts Please supply the following informationBurn Hazards Respiratory HazardsEquipment Damage Rotating Parts HazardsGDP-5H Rules for Safe Operation Read this manualGDP-5H Rules for Safe Operation Death EmergenciesMachine Safety Decals Operation and Safety DecalsGDP-5H Specifications Generator Effects of Altitude and HeatSpecifications Engine GDP-5H Dimensions DimensionsPhase Vibrator Application GeneratorControl Box Excitation SystemExtension Cables Single Phase Load 60 HzGDP-5H Load Application Three Phase Load 180 Hz How to UseGround the Generator Ground the ToolGDP-5H Controls and Indicators GDP-5H Controls and Indicators 240V Full Power SwitchFuelTank Fuel tank capacity is 5 gallons 19 liters GDP-5H Generator Refueling Generator RefuelingGDP-5H Installation Outdoor InstallationIndoor Installation MountingGDP-5H Installation Connecting the GroundExtension Cable General Inspection Prior to Operation Ground Power ToolsGDP-5H PRE-INSPECTION GDP-5H PRE-INSPECTION Engine Before StartingEngine Oil Check Fuel Check180 Hz Circuit Breakers OFF Position Starting the Engine Choke LeverGDP-5H Initial START-UP/GENERATOR Operation Connecting the Load Hz Output ReceptaclesStopping the Engine Generator StorageGDP-5H Maintenance Engine Engine Maintenance ScheduleSpark Plug Gap Engine Oil DrainingGDP-5H Wiring Diagram Generator S/N 5541049 and below GDP-5H -WIRING Diagram Generator S/N 5543731 and Above GDP-5H -TROUBLESHOOTING Engine GDP-5H -TROUBLESHOOTING Engine GDP-5H -TROUBLESHOOTING Generator Page How to read the marks and remarks used in this parts GDP-5H Explanation of Code in Remarks ColumnItems Found In the Remarks Column Items Found In the Items Number ColumnTo 3 Units DescriptionGDP-5H Nameplate and Decals GDP-5H Nameplate and Decals Part Name QTY RemarksGDP-5H Generator Assy SET Bolt Rotor GDP-5H Control BOX Assy Control BOX GDP-5H Muffler Assy GDP-5H Muffler Assy GDP-5H Pipe Frame Assy Pipe Frame Honda GX340K1EDN2 Engine AIR Cleaner Assy Part Name Honda GX340K1EDN2 Engine Camshaft Assy ROD, Push Honda GX340K1EDN2 Engine Carburetor Assy Gasket SET Honda GX340K1EDN2 Engine Control Assy ARM, Governor Honda GX340K1EDN2 Engine Crankcase Cover Assy GASKET, Case Cover Honda GX340K1EDN2 Engine Crankshaft Assy Part Name QTY. Remarks Honda GX340K1EDN2 Engine Cylinder Barrel Assy Switch ASSY., OIL Level Honda GX340K1EDN2 Engine Cylinder Head Assy Cylinder Head Honda GX340K1EDN2 Engine FAN Cover Assy COVER, FAN *NH1* Black Honda GX340K1EDN2 Engine Flywheel Assy FAN, Cooling Honda GX340K1EDN2 Engine Ignition Coil Assy Coil ASSY., Ignition Honda GX340K1EDN2 Engine Piston Assy Piston STD Honda GX340K1EDN2 Engine Recoil Starter Assy PULLEY, Recoil Starter Honda GX340K1EDN2 Engine Solenoid Assy SPRING, Choke Return Honda GX340K1EDN2 Engine Labels Assy Emblem Effective October 1, 2002 Terms and Conditions of Sale Parts Page Your Local Dealer is