Guardian Technologies 5209 owner manual Owner’s Manual

Page 1

Owner’s

Manual

•SAFETY

•ASSEMBLY

•OPERATION

•TROUBLESHOOTING

•ELECTRICAL DATA

•PARTS

•WARRANTY

AUTHORIZED DEALER SUPPORT:

1-800-333-1322

ULTRA SOURCE

Semi-Automatic

Emergency Generator

COMMERCIAL • INDUSTRIAL • RESIDENTIAL

MODEL: 005209

15,000 WATT GENERATOR AND 100 AMP TRANSFER SWITCH WITH BUILT-IN LOAD CENTER

Image 1

Contents Owner’s Manual Installation Guide For Generator Ready Kit Introduction General Hazards Important Safety InstructionsExplosion Hazards Electrical HazardsFire Hazards Accessory BOX AssemblyUnpacking Assembling the Wheel KITHandle Assembly Battery ConnectionKnow the Generator Operation1 AC, 20 AMP, Duplex Receptacle Cord Sets and Connection Plugs2 120V AC, 20 AMP, Gfci Receptacle Provided. This receptacle can not recharge 6 Volt batteries 5 12 Volt DC, 10 AMP ReceptacleConnecting Electrical Loads HOW to USE the GeneratorDON’T Overload the Generator Grounding the GeneratorBefore Starting the Generator Wattage Reference GuideAdding Engine OIL Adding Gasoline To Start the EngineAutomatic Idle Control Stopping the EngineCold Weather OPERATION/ DE-ICER LOW OIL Pressure Shutdown SystemTo recharge 12 Volt batteries, proceed as follows Charging a BatteryProduct Specifications Maintenance ScheduleGenerator Specifications Engine SpecificationsEngine Maintenance Checking OIL Level Generator MaintenanceTo Clean the Generator General RecommendationsClean Spark Arrestor Screen Service AIR CleanerReplacing the Spark Plug To adjust valve clearance Adjusting Valve ClearanceLong Term Storage GeneralOther Storage Tips Fuel TankSymptom Cause Solution TroubleshootingGenerator Ready KIT Plan the Location of Your Generator Safety and to discourage tampering Your Guardian Generator Ready KIT Is NOW Installed Operation of Generator with Generator Ready KIT Transfer to Generator Power Source When Utility Power Fails Interconnection Drawing Residential Portable Generator System Wiring Diagram Drawing No E0228 Schematic Drawing No E0229-A Section Part NO. QTY Description Detail a QTY Description Part NO#.QTY Generator Drawing No D4488-D QTY. Description 47,48 Heatsink Part NO. QTY. DescriptionFrame, Handle & Wheel Kit Drawing No E0695-A Special L/WASH QTY DescriptionCalifornia Emission Control Warranty Statement Emission Control System Warranty This Warranty Shall not Apply to the Following Warranty Schedule