Dixon ZTR 30, 14186-0303 manual Care and Maintenance

Page 36

CARE AND MAINTENANCE

Deck Removal - Zeeter 42”

1.Place cut height lever in lowest cut position.

2.Pull belt idler back to allow belt to be removed from idler pulley and electric clutch pulley.

3.Remove hair pin cotter and washer from one end of deck support cross shaft. Note location of remaining shim washers used between chassis and mower deck plates. Slide shaft from chassis and mower deck.

4.Remove hair pin cotter and washer from each deck L-rod. Remove L-rods from lift arms. At this point, deck will drop down.

5.Carefully raise and support front of chassis. Slide mower deck to either side for removal. (Reverse procedure to reinstall deck assembly.)

Note:	When deck is reinstalled on frame, check that
	belt is correctly routed in the groves of all
	pulleys and that belt idler is applying tension to
	the back side of the belt.

36

Image 36

Contents Zeeter Model OPERATOR’S ManualImportant Read Carefully D E Safety Blade Contact TIP Over RUN Over Back OverSafety Alert Symbol General Operation General Operation Slope Operation Slope Operation Do notI L D R E N R V I C E Service CUT-MORE Specification S ZeeterFront body contains access panel for battery service GA stamped steel construction. Three blades Controls Control LeversParking Brake To SET Parking BrakeTransmission Drive System Blade DriveThrottle Control Lever Mower Deck CUT Height Lift LeverOperation Instructions W I N GBefore Operating Mower Starting Instructions Testing of Safety Interlock Systems Parking Brake Switch TestEngine should Stop Side Discharge of the Clippings Grass Height and Cutting Suggestions Mowing with a Mulching Attachment Mowing with a Mulching Attachment CUT High MOW OftenCare and Maintenance MaintenanceOFF Season Battery Storage G I N ET T E R Y Cutter Blade Maintenance R E S L T S Belt TensionBelts Deck Removal Zeeter Care and Maintenance Care and Maintenance Service Intervals B R I C a T I O NChassis LocationsChanging the Engine OIL OIL Fill Drive System Adjustments Rear Chain Adjustment MaintenanceCleaning the Mower WarrantyPARTS/SERVICE Electrical SystemsStandard Service Parts List Zeeter ModelBlades Briggs & Stratton AIR and OIL Filter Part NumbersTroubleshooting Engine WON’T Turn OverEngine Runs but Mower WON’T Move Forward Page Owner Information Name AddressZTRMowers